Because an air dryer is pressurized and contains me-
chanical parts, the same precautions should be observed
as with any piece of machinery of this type where care-
lessness in operation or maintenance is hazardous to per-
sonnel. In addition to the many obvious safety rules that
should be followed with this type of machinery, the safety
precautions as listed below must be observed:
1. Only qualifi ed personnel shall be permitted to adjust,
perform maintenance or repair this air dryer.
2. Read all instructions completely before operating unit.
3. Pull main electrical disconnect switch and disconnect
any separate control lines, if used, before attempting to
work or perform maintenance on the unit.
4. Do not attempt to service any part while dryer is in an
operational mode.
5. Do not attempt to remove any parts without fi rst reliev-
ing the entire air system of pressure.
6. Do not operate the dryer at pressures in excess of its
rating.
7. Inspect unit daily to observe and correct any unsafe
operating conditions.
OSHA Heading Descriptions
5.0 SAFETY AND OPERATION PRECAUTIONS
ZEKS Eclipse ZPA 90-5000 Desiccant Dryers
www.zeks.com
4
!
NOTICE
The user of any air dryer manufactured by ZEKS Com-
pressed Air Solutions, is hereby warned that failure to
follow the above Safety and Operation Precautions can
result in personal injuries or equipment damage. How-
ever, ZEKS Compressed Air Solutions does not state as
fact, nor does it mean to imply, that the preceding list of
Safety and Operating Precautions is all inclusive, and
further, that the observance of this list will prevent all
personal injuries or equipment damage.
!
WARNING
“Warning” is used to indicate a hazardous situation which
has some probability of death or severe injury. Warn-
ing should not be considered for property damage ac-
cidents unless personal injury risk is present.
!
CAUTION
“Caution” is used to indicate a hazardous situation which
may result in minor or moderate injury.
!
NOTICE
“Notice” is used to indicate a statement of company
policy as the message relates directly or indirectly to
the safety of personnel or protection of property. Notice
should not be associated directly with a hazard or haz-
ardous situation and must not be used in place of “Dan-
ger,” “Warning,” or “Caution.”
To Next Page
Loading...