A.O. Smith BTH 400 - Air Requirements; Confined Space Air Requirements

17
UNUSUALLY TIGHT CONSTRUCTION
,QXQFRQ¿QHGVSDFHVLQEXLOGLQJV LQ¿OWUDWLRQPD\EHDGHTXDWH
WR SURYLGH DLU IRU FRPEXVWLRQ YHQWLODWLRQ DQG GLOXWLRQ RI ÀXH
JDVHV+RZHYHULQEXLOGLQJVRIXQXVXDOO\WLJKWFRQVWUXFWLRQIRU
H[DPSOH ZHDWKHU VWULSSLQJ KHDYLO\ LQVXODWHG FDXONHG YDSRU
EDUULHUHWFDGGLWLRQDODLUPXVWEHSURYLGHGXVLQJWKHPHWKRGV
GHVFULEHGLQWKH&RQ¿QHG6SDFHVHFWLRQWKDWIROORZV
CONFINED SPACE
$&RQ¿QHG6SDFHLVRQHZKRVHYROXPHIS LESS THANFXELF
IHHWSHU%WXKUFPSHUN:RIWKHWRWDOLQSXWUDWLQJRI
DOODSSOLDQFHVLQVWDOOHGLQWKHVSDFH
2SHQLQJVPXVWEHLQVWDOOHGWRSURYLGHIUHVKDLUIRUFRPEXVWLRQ
YHQWLODWLRQDQGGLOXWLRQLQFRQ¿QHGVSDFHV7KHUHTXLUHGVL]HIRU
WKHRSHQLQJVLVGHSHQGHQWRQWKHPHWKRGXVHGWRSURYLGHIUHVK
DLUWRWKHFRQ¿QHGVSDFHAND the total Btu/hr input rating of all
DSSOLDQFHVLQVWDOOHGLQWKHVSDFH
DIRECT VENT APPLIANCES
$SSOLDQFHVLQVWDOOHGLQD'LUHFW9HQWFRQ¿JXUDWLRQWKDWGHULYHDOO
DLUIRUFRPEXVWLRQIURPWKHRXWGRRUDWPRVSKHUHWKURXJKVHDOHG
LQWDNHDLUSLSLQJDUHQRWIDFWRUHGLQWKHWRWDODSSOLDQFHLQSXW%WX
KUFDOFXODWLRQVXVHGWRGHWHUPLQHWKHVL]HRIRSHQLQJVSURYLGLQJ
IUHVKDLULQWRFRQ¿QHGVSDFHV
EXHAUST FANS
:KHUHH[KDXVWIDQVDUHLQVWDOOHGDGGLWLRQDODLUVKDOOEHSURYLGHG
WRUHSODFH WKHH[KDXVWHG DLU:KHQ DQH[KDXVW IDQLVLQVWDOOHG
LQ WKH VDPH VSDFH ZLWK D ZDWHU KHDWHU VXI¿FLHQW RSHQLQJV WR
SURYLGH IUHVK DLU PXVW EH SURYLGHG WKDW DFFRPPRGDWH WKH
UHTXLUHPHQWVIRUDOODSSOLDQFHVLQWKHURRPDQGWKHH[KDXVWIDQ
8QGHUVL]HG RSHQLQJV ZLOO FDXVH DLU WR EH GUDZQ LQWR WKH URRP
WKURXJKWKHZDWHUKHDWHU¶VYHQWV\VWHPFDXVLQJSRRUFRPEXVWLRQ
6RRWLQJVHULRXVGDPDJHWRWKHZDWHUKHDWHUDQGWKHULVNRI¿UH
RUH[SORVLRQPD\UHVXOW,WFDQDOVRFUHDWHDULVNRIDVSK\[LDWLRQ
LOUVERS AND GRILLES
7KHIUHHDUHDVRIWKHIUHVKDLURSHQLQJVLQWKHLQVWUXFWLRQVWKDW
IROORZGRQRWWDNHLQWRDFFRXQWWKHSUHVHQFHRIORXYHUVJULOOHVRU
VFUHHQVLQWKHRSHQLQJV
7KH UHTXLUHG VL]H RI RSHQLQJV IRU FRPEXVWLRQ YHQWLODWLRQ DQG
GLOXWLRQDLUVKDOOEHEDVHGRQWKH³QHWIUHHDUHD´RIHDFKRSHQLQJ
:KHUHWKHIUHHDUHDWKURXJKDGHVLJQRIORXYHURUJULOOHRUVFUHHQ
LVNQRZQLWVKDOOEHXVHGLQFDOFXODWLQJWKHVL]HRIWKHRSHQLQJ
UHTXLUHGWRSURYLGHWKHIUHHDUHDVSHFL¿HG:KHUHWKHORXYHUDQG
JULOOHGHVLJQDQG IUHHDUHDDUHQRWNQRZQLWVKDOO EHDVVXPHG
WKDWZRRGORXYHUVZLOOKDYHIUHHDUHDDQGPHWDOORXYHUVDQG
JULOOHVZLOOKDYHIUHHDUHD1RQPRWRUL]HGORXYHUVDQGJULOOHV
VKDOOEH¿[HGLQWKHRSHQSRVLWLRQ
AIR REQUIREMENTS
Breathing Hazard - Carbon Monoxide Gas
Install water heater in accordance with
the Instruction Manual and NFPA 54 or
CAN/CSA-B149.1.
To avoid injury, combustion and ventilation
air must be taken from outdoors.
Do not place chemical vapor emitting
products near water heater.
Breathing carbon monoxide can cause brain damage or
death. Always read and understand instruction manual.
)RUVDIHRSHUDWLRQDQDGHTXDWHVXSSO\RIIUHVKXQFRQWDPLQDWHG
DLUIRUFRPEXVWLRQDQGYHQWLODWLRQPXVWEHSURYLGHG
$QLQVXI¿FLHQWVXSSO\RIDLUFDQFDXVHUHFLUFXODWLRQRIFRPEXVWLRQ
SURGXFWV UHVXOWLQJ LQ FRQWDPLQDWLRQ WKDW PD\ EH KD]DUGRXV WR
OLIH6XFKDFRQGLWLRQRIWHQZLOOUHVXOWLQD\HOORZOXPLQRXVEXUQHU
ÀDPHFDXVLQJVRRWLQJRIWKHFRPEXVWLRQFKDPEHUEXUQHUVDQG
ÀXHWXEHVDQGFUHDWHVDULVNRIDVSK\[LDWLRQ
'R QRW LQVWDOO WKH ZDWHU KHDWHU LQ D FRQ¿QHG VSDFH XQOHVV DQ
DGHTXDWHVXSSO\RIDLUIRUFRPEXVWLRQDQGYHQWLODWLRQLVEURXJKW
LQ WR WKDW VSDFH XVLQJ WKH PHWKRGV GHVFULEHG LQ WKH &RQ¿QHG
6SDFHVHFWLRQWKDWIROORZV
1HYHUREVWUXFWWKHÀRZRIYHQWLODWLRQDLU,I\RXKDYHDQ\GRXEWV
RUTXHVWLRQVDWDOOFDOO\RXUJDVVXSSOLHU)DLOXUHWRSURYLGHWKH
SURSHUDPRXQWRIFRPEXVWLRQDLUFDQUHVXOWLQD¿UHRUH[SORVLRQ
DQGFDXVHSURSHUW\GDPDJHVHULRXVERGLO\LQMXU\RUGHDWK
UNCONFINED SPACE
$Q8QFRQ¿QHG6SDFHLVRQHZKRVHYROXPHIS NOT LESS THAN
FXELFIHHWSHU%WXKUFXELFPHWHUVSHUN:RIWKH
WRWDOLQSXWUDWLQJRIDOODSSOLDQFHVLQVWDOOHGLQWKHVSDFH5RRPV
FRPPXQLFDWLQJGLUHFWO\ZLWKWKHVSDFHLQZKLFKWKHDSSOLDQFHV
DUH LQVWDOOHG WKURXJK RSHQLQJV QRW IXUQLVKHG ZLWK GRRUV DUH
FRQVLGHUHGDSDUWRIWKHXQFRQ¿QHGVSDFH
0DNHXS DLU UHTXLUHPHQWV IRU WKH RSHUDWLRQ RI H[KDXVW IDQV
NLWFKHQYHQWLODWLRQV\VWHPV FORWKHV GU\HUV DQG¿UHSODFHV VKDOO
DOVREH FRQVLGHUHGLQ GHWHUPLQLQJ WKHDGHTXDF\ RID VSDFHWR
SURYLGHFRPEXVWLRQYHQWLODWLRQDQGGLOXWLRQDLU