ACP RCS10DSE - User Manual

Commercial Microwave-Technical Information
August 2012 16500040
©2012 ACP Inc.
1
120 VAC, 60 Hz model
RCS10DSE P2001102M
MCS10DSE P2001104M
• Due to possibility of personal injury or property damage, always contact an authorized technician for servicing or
repair of this unit.
• Refer to Service Manual for installation, operating, testing, troubleshooting, and disassembly instruction.
CAUTION
!
All safety information must be followed as provided in Service Manual.
!
WARNING
To avoid the risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor
before servicing, unless testing requires power.
Models RCS10DSE / MCS10DSE
Power Source
Voltage AC 120 VAC
Amperage (Single Unit) 15 A
Frequency 60 Hz
Single Phase, 3 wire grounded X
Receptacle 5-15R
Plug 5-15P
Power Output −
−−
− Microwave
Nominal microwave energy (IEC705) 1000 Watts
Minimum temperature rise (ΔT)
10ºF / 5ºC
Operating Frequency 2450 MHz
Power Consumption
Microwave only 1550 Watts
Dimensions
Cabinet (in cm)
Width 22" 56 cm
Height 13 3/4" 34.9 cm
Depth 19" 48.2 cm
Oven Interior (in cm)
Width 14 1/2" 36.8 cm
Height 8 1/2" 21.6 cm
Depth 15 " 38.1 cm
Weight
Uncrated 41 lbs. 18.6 kg
Features
Timer 10 minute single speed
Cavity Volume 1.2 cu. Ft.

Summary

Technical Specifications

Power Source Specifications

Details voltage, amperage, frequency, and plug/receptacle types for the microwave.

Microwave Power Output

Specifies nominal microwave energy output and operating frequency.

Dimension Details

Provides cabinet and oven interior dimensions in inches and centimeters.

Weight Information

Lists the weight of the microwave, uncrated.

Key Features

Describes basic features like timer type and cavity volume.

Component Testing Procedures

Thermal Cutout and Diode Tests

Tests thermal cutout resistance and diode resistance across capacitor leads.

Capacitor and Magnetron Resistance

Tests capacitor resistance between terminals/case and magnetron resistance to ground.

Motor and Transformer Resistance

Measures resistance across blower/stirrer motors and transformer windings.

Lamp, Receptacle, and Harness Tests

Tests continuity of the oven light receptacle and wire harness.

Additional Component Testing

Fuse Block and Interlock Switch Tests

Tests power terminals of fuse block and resistance of interlock switches with door open/closed.

Dial Electronic Control Tests

Measures voltage at CN1 and across relay terminals for diagnostic purposes.

Microwave Power Output Test

Power Test Equipment and Notes

Lists required equipment and important notes for performing the power output test.

Power Test Procedure

Step-by-step guide to heating water and measuring temperature rise for power verification.

Temperature Rise Table

Reference table correlating temperature rise (ΔT) to cooking power output in Fahrenheit and Celsius.

Wiring Diagram and Schematic

Schematic Diagram Overview

Visual representation of the microwave's electrical components and their interconnections.

Wiring Color Code and Notes

Key for wire colors and essential notes for servicing the unit.

ACP RCS10DSE Specifications

General

Type	Countertop
Output Power	1000 W
Capacity	1.0 cu. ft.
Power Levels	10
Defrost	Yes
Display	LED
Exterior Finish	Stainless Steel
Voltage	120 V
Frequency	60 Hz
Control Type	Touch
Turntable Diameter	12.4 inches