ADC ADG-75D - Specifications

76 pages

To Next Page

To Previous Page

Specifications

ADG-75D (Gas)

ADE-75 (Electric)

ADS-75 (Steam)

NOTE: ADC RESERVES THE RIGHT TO MAKE CHANGES IN SPECIFICATIONS AT

ANY TIME, WITHOUT NOTICE or OBLIGATION.

Main Page

What to Do if You Smell Gas1
Table of Contents5
Receiving and Handling7
Specifications10
Specifications11
Component Identification12
Product View12
Dryer Front View12
Dryer Rear View13
Installation Procedures14
Location Requirements14
Unpacking/Setting up15
Leveling Dryer15
Dryer Enclosure Requirements16
Fresh Air Supply17
Exhaust Requirements18
General Exhaust Duct Work Information18
Horizontal Venting18
Vertical Venting18
Outside Duct Work Protection19
Single Dryer Venting19
Multiple Dryer (Common) Venting21
Electrical Requirements23
Electrical Information23
Electrical Service Specifications24
Grounding26
Electrical Connections26
Gas Supply31
Gas Information31
Technical Gas Data32
Piping/Connections33
Steam Information34
Steam Coil PH Level34
Steam Requirements - High Pressure35
Steam Lines Installation35
Steam Damper Air System Connections37
Steam Damper System Operation38
Steam Damper Air Piston (Flow Control) Operation Adjustment39
Preparation for Operation/Start-Up40
Preoperational Tests41
Preoperational Instructions43
Shut down Instructions44
Service/Parts Information45
Warranty Information46
Returning Warranty Cards46
Returning Warranty Parts46
Routine Maintenance48
Cleaning48
Adjustments50
Functional Check of Replacement Components51
Microprocessor (Computer) Board51
Direct Spark Ignition (DSI) System52
Reversing Timer Spin/Dwell Adjustments53
Section VIII53
Technical Information54
Data Label54
Troubleshooting56
No LED Display58
Drive Motor Is Not Operating (Does Not Start)58
Drive Motor Operates in One Direction Only58
Drive Motor Operates Okay for a few Minutes, then Stops58
Blower/Fan Motor Is Not Operating (Does Not Start)59
Blower/Fan Motor Operates Okay, then Stops59
Both Drive Motor and Blower Motor Not Operating59
Both Drive Motor and Blower (Impeller/Fan) Motor Run and Stop59
Microprocessor LED Display Reads "Dsfl" Continuously60
Microprocessor Controller LED Display Reads "Door"60
Microprocessor Controller will Not Accept Keyboard Entries60
Microprocessor Controller will Only Accept Certain Keyboard Entries60
Dryer Stops During a Cycle, Microprocessor Controller Buzzer Sounds61
Microprocessor Controller LED Display Reads "SEFL"61
Microprocessor Controller LED Display Reads "Hot"61
Heating Unit Is Not Operating (no Heat), no Voltage at Heating Unit62
Dryer Operates but Is Taking too Long to Dry64
At Completion of "Auto" Cycle the Load Is Coming out over Dried66
At Completion of "Auto" Cycle the Load Is Coming out Still Damp66
Main Burners Are Burning with a Yellow Flame67
Condensation on Main Door Glass67
Scraping Noise at Basket (Tumbler) Area67
Excessive Noise And/Or Vibration67
Both Driver and Motor and Blower Motor Are Not Operating68
No Heat, no Voltage at Heating Unit71

ADC ADG-75D - Specifications

Table of Contents

Related product manuals