12
NOTE: Should replacement filters be needed, please
contact an Airxcel, Inc. Authorized Service Center or
Airxcel, Inc. direct for replacements. The filters used
in our products are factory recommended for the
best performance.
Our warranty will not support any filters such as
HEPA filters or any other material not specifically
recommended by Airxcel, Inc.
II. Service Person
A. Electrical – All electrical work and/or inspection
should be performed only by qualified service
personnel. Contact your nearest Airxcel, Inc.
Service Center if electrical problems should arise.
B. Check Points – Failure to start or to cool the air
are sometimes problems with air conditioner
units. The Coleman-Mach RV air conditioner is
designed to operate on 115 volt electrical power.
If the compressor on the air conditioner fails to
start, check with your Airxcel, Inc. Service Center
to determine that the proper wire size is
connected to the unit, the proper circuit breakers
are installed as protection devices on the
electrical circuit and the proper sized extension
cord is being used for the distance covered from
the utility outlet to the RV. The required minimum
wire size is #12 AWG for lengths up to 25 feet
(larger wire size for greater distances). Each air
conditioner unit must be protected with a 20 amp
time delay fuse or circuit breaker.
If the air conditioner continues to trip off the circuit
breakers, have an electrician check the starting
amperage and running amperage on the unit. If
the circuit breaker continues to trip off and the
electrical consumption is found to be normal, it
will require the replacement of the faulty circuit
breaker.
If all electrical power to the air conditioner is
normal but neither the fan or the compressor will
operate, the connector plug located behind the
ceiling assembly control box should be checked
to determine whether it is faulty.
C. Mechanical Integrity – The air conditioner should
be inspected periodically to be sure that the bolts
which secure the unit to the roof are tight and in
good shape. Also, an examination of the plastic
shroud covering the Air conditioner on the top of
the roof should be made periodically. Be sure the
four mounting screws and washers are snug and
holding the shroud to the Air conditioner. Also,
examine the shroud to be sure it is not developing
cracks or has suffered damage from impact.
v. WALL THERMOSTAT IDENTIFICATION AND
OPERATION
If your Coleman-Mach roof top unit is controlled by a
wall thermostat, refer to the operation manual that was
included with the thermostat.
vi. WARRANTY SERVICE
Let’s face it. Sometimes even the best products may
need service. To obtain warranty service on your
Coleman-Mach Air conditioner, please contact your
selling dealer, or you may access our web site on the
Internet at www.Airxcel.com for answers to the most
frequently asked questions and service center
locations.
Airxcel, Inc. support help may be accessed by e-mail
at RVPSupport@Airxcel.com. All written
correspondence should be directed to:
AIRXCEL, INC. - RV Products Division
P.O. Box 4020
Wichita, KS 67204
IMPORTANT
1. Carefully read the LIMITED 2 YEAR WARRANTY,
the OPTIONAL THREE YEAR EXTENDED PARTS
WARRANTY, sample contract, terms, conditions,
exceptions and exclusions regarding your unit at
www.Airxcel.com.
2. An optional three year extended parts only contract
is available at an additional cost of $89.95. To obtain
this optional three year parts contract, fill out the
application located on the back of this manual. Once
completed, cut along the dotted lines and mail the
application and your check or money order to the
address above. Applications must be made within
ninety (90) days of the original purchase.
3. Inquiries about your Coleman-Mach air conditioner
must include the model and serial numbers and the
date of purchase. The model and serial numbers
can be found on the I.D. label located on the air
conditioner basepan return air opening at the
bottom of the roof top unit. This information may
also be found on the air conditioner rating plate.
To Next Page
Loading...
Need help?
General
