ALLIANCE 120 Series User Manual

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
70458101 (EN)
3
© Copyright 2013, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any
means without the expressed written consent of the publisher.
Table of
Contents
Introduction......................................................................................... 6
Model Identification ............................................................................. 6
Contact Information.............................................................................. 7
Safety Information.............................................................................. 8
Important Safety Instructions ............................................................... 9
Specifications and Dimensions........................................................... 11
120 Series Tumble Dryer Dimensions and Exhaust
Outlet Locations ................................................................................. 12
170 and 200 Series Tumble Dryer Dimensions and
Exhaust Outlet Locations ................................................................... 13
Electric and Gas Connection Locations for
Gas Models Through 3/10/13............................................................. 14
Electric and Gas Connection Locations for
Gas Models Starting 3/11/13.............................................................. 15
Electric and Steam Connection Locations for
Steam Models Through 3/10/13......................................................... 16
Electric and Steam Connection Locations for
Steam Models Through 3/11/13......................................................... 17
Electric Connection Location for Electric Models ............................... 18
Installation........................................................................................... 19
Pre-Installation Inspection .................................................................... 19
Location Requirements......................................................................... 19
Position and Level the Tumble Dryer................................................... 21
Fire Suppression System....................................................................... 21
Check Local Codes and Permits ...................................................... 21
Water Requirements......................................................................... 21
Water Connections........................................................................... 22
Electrical Requirements ................................................................... 23
Auxiliary Alarm ............................................................................... 23
Before Placing Tumble Dryer into Service .......................................... 24
Required for CE Models Only ......................................................... 25
Installing CE Gas Drying Tumble Dryer.............................................. 26
General Information......................................................................... 26
CE Orifices....................................................................................... 27
Properties of CE Gases .................................................................... 27
Basic Configuration ......................................................................... 28
Specific Conversion Procedures ...................................................... 28
Exhaust Requirements ....................................................................... 30
Layout ................................................................................................... 30
Make-Up Air......................................................................................... 30
Venting ................................................................................................. 30
Individual Venting ........................................................................... 32
Manifold Venting............................................................................. 32
Gas Requirements............................................................................... 36
Gas Supply Pipe Sizing and Looping ................................................... 38
High Altitude Orifice Sizing................................................................. 40

ALLIANCE 120 Series Specifications

General

Brand	ALLIANCE
Model	120 Series
Category	Dryer
Language	English