EGG STATION DUAL ZONE
MODEL ESDZ-1200
Mfg. No. 9300626 & 9300632
Place this manual in the Small Equipment/
Miscellaneous section of your Equipment Manual.
Manufactured exclusively for
McDONALD’S
®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
TABLE OF CONTENTS
This manual is for the exclusive use of licensees and employees of McDonald’s Systems, Inc.. © McDonald’s Corporation All Rights Reserved.
See back cover for important warranty information.
Owner Information .....................................................2
General ......................................................................2
Warranty Information .................................................2
Service/Technical Assistance ....................................2
Important Safety Information ....................................3
Specifications .............................................................4
Electrical Ratings .......................................................4
Dimensions ................................................................4
Electrical Cord & Plug Configurations .......................4
Installation ...................................................................5
Unpacking ..................................................................5
Leveling the Unit ........................................................5
Operation .....................................................................6
Preparing Unit ............................................................6
Control Panel .............................................................6
Egg Cooking Procedure ............................................7
Best Practices .............................................................8
Troubleshooting for Under Cooked Eggs ..................8
Troubleshooting Eggs leaking out of Egg Rings .......8
Programming ..............................................................9
Factory Default Cooking Times .................................9
Turning cooking surfaces on or off ............................9
Manager Mode ..........................................................9
Maintenance .............................................................. 10
Daily Cleaning .............................................................
10
TROUBLESHOOTING ............................................... 11
Error Codes .............................................................12
Hi Limit Control ........................................................12
Factory Reset ..........................................................12
Replacement Parts ...................................................13
Wiring Diagram .........................................................17
LIMITED WARRANTY .........................................................20
1
P/N 1011416 Rev. H 02/18
Scan with mobile device or enter URL
for product and service information.
Antunes
ESDZ-1200
http://tiny.cc/ajaESDZ
IMPORTANT
The unit must be level before use. Before using the unit, adjust the legs of the unit as needed and use a
level (if available) to ensure the unit is level. If a level is not available, pour a small amount of water directly
onto the center of the cool grill surface. If the unit is level, the water should pool in the middle and not drain
toward a certain section of the unit. Make adjustments as required. Turn legs clockwise to shorten or
counter-clockwise to lengthen. See image (Side view of unit).
Turn Leg
Clockwise
to shorten.
Turn Leg
Counter-clockwise
to lengthen.
To Next Page
General
