MANUAL EGG STATION
MODEL MES-1200 WITH TIMER
Manufacturing Numbers 9300605 & 9300606
Place this manual in the Small Equipment/
Miscellaneous section of your Equipment Manual.
Manufactured exclusively for
McDONALD’S
®
BY
ANTUNES
180 KEHOE BLVD.
CAROL STREAM, ILLINOIS 60188, U.S.A.
PHONE: +1-630-784-1000
TOLL FREE: +1-877-392-7854
FAX: +1-630-784-1650
www.antunes.com
TABLE OF CONTENTS
This manual is for the exclusive use of licensees and employees of McDonald’s Systems, Inc.. © McDonald’s Corporation All Rights Reserved.
See back cover for important warranty information.
Owner Information .....................................................2
General ......................................................................2
Warranty Information .................................................2
Service/Technical Assistance ....................................2
Important Safety Information ....................................3
Specifications .............................................................5
Electrical Ratings .......................................................5
Dimensions ................................................................5
Electrical Cord & Plug Configurations .......................5
Installation ...................................................................6
Unpacking ..................................................................6
Leveling the Unit ........................................................6
Timer Interface ..........................................................6
Operation .....................................................................7
Preparing Unit ............................................................7
Best Practices .............................................................8
Troubleshooting for Under Cooked Eggs ..................8
Troubleshooting Eggs leaking out of Egg Rings .......8
Programming ..............................................................9
MES-1200 Setpoint Temperature ..............................9
Maintenance .............................................................. 10
Daily Cleaning .........................................................10
Checking Grill Surface Temperature .......................10
Troubleshooting ....................................................... 11
Wiring Diagram .........................................................12
Replacement Parts ...................................................13
LIMITED WARRANTY ...............................................16
1
P/N 1011407 Rev. D 03/18
McDonald’s
Scan with mobile device or enter URL
for product and service information.
MES-1200
http://tiny.cc/ajaMES1200
IMPORTANT
The unit must be level before use. Before using the unit, adjust the legs of the unit as needed and use a
level (if available) to ensure the unit is level. If a level is not available, pour a small amount of water directly
onto the center of the cool grill surface. If the unit is level, the water should pool in the middle and not drain
toward a certain section of the unit. Make adjustments as required. Turn legs clockwise to shorten or
counter-clockwise to lengthen. See image (Side view of unit).
Turn Leg
Clockwise
to shorten.
Turn Leg
Counter-clockwise
to lengthen.
To Next Page
General
