Ariens Imperial RM1028 User Manual (English)

Questions and Answers:

L
Lisa LynchAug 6, 2025
How to fix Ariens Imperial RM1028 Lawn Mower if starter will not operate?
- I
  Isaiah RossAug 6, 2025
  If your Ariens Lawn Mower starter won't operate when you turn the ignition key to the "S" position, there are several potential causes. The battery might be discharged, so try charging it. Also, check for loose battery cables and tighten them if necessary. It could also be a defective solenoid switch or starter, in which case you should replace them. A blown fuse or a faulty interlock switch could also be the culprit, so replace them if needed.
L
lnguyenAug 14, 2025
What to do if Ariens Imperial RM1028 won't move forward or reverse?
- K
  Kara SchwartzAug 14, 2025
  If your Ariens Lawn Mower tractor won't move when you shift into forward or reverse, first, adjust the Fwd-Rev clutch. Second, make sure the transmission disconnect is engaged. Finally, check if the PTO belt is off and reattach it if necessary.
R
Richard RamirezAug 20, 2025
Why does my Ariens Imperial RM1028 engine stop when PTO is engaged?
- F
  Frank ClarkeAug 20, 2025
  If your Ariens Lawn Mower engine stops when you engage the PTO or Fwd-Rev, it could be due to several reasons. First, make sure the PTO is disengaged. Second, ensure the shift lever is in the neutral position. Third, check that the operator presence seat switch is pressed. If these aren't the issue, the seat switch may be faulty and require replacement, or the wiring to the PTO switch may be incorrect and need correction.
G
Garrett Steele MDAug 28, 2025
Why does my Ariens Imperial RM1028 engine start but runs rough?
- S
  Sara WangAug 28, 2025
  If your Ariens Lawn Mower engine starts but runs roughly, the air cleaner element might be restricted, so clean or replace it. Another cause could be the engine choke being in the "ON" position, so turn it off. Also, the fuel cap vent might be restricted; check and clear it. For engine carburetor malfunction, refer to the Engine Manual for instructions.

Ariens Imperial RM1028 Specifications

General

Brand	Ariens
Model	Imperial RM1028
Category	Lawn Mower
Language	English

Summary

CONTROLS AND FEATURES

Control Identification

Identifies and lists the numbered controls and features of the riding mower.

INTRODUCTION

Manual, Service, and Registration

Covers the manual's purpose, service/parts ordering, and product registration.

Disclaimer

States Ariens Company's right to make changes and disclaims liability for unauthorized parts.

SAFETY

Safety Symbols, Signal Words, and Practices

Explains safety symbols, signal words, general precautions, and decal locations.

OPERATIONAL SAFETY RULES

Unit, Personal, and Maintenance Safety

Details safety for unit operation, clear area, personal gear, child safety, and maintenance.

SPECIFIC SAFETY HAZARDS

Fuel, Exhaust, Slopes, and Battery Hazards

Covers safety related to fuel, exhaust fumes, slopes, parking, battery, and sharp edges.

TRANSPORT AND ATTACHMENT SAFETY

Transport, Rolling, and Bagger Safety

Details safe practices for transporting, rolling, using attachments, and operating with a bagger.

OPERATION

Standard Controls and Ignition

Introduces standard controls, throttle/choke, and ignition switch operation.

Starting Systems and Pedals

Details electric/recoil start, brake, and clutch pedal operations.

Speed Selector and Attachment Clutch

Explains how to use the speed selector and attachment clutch.

OPERATION DETAILS

Attachment Lift, Parking Brake, and Pre-Start Checks

Covers attachment lift, parking brake, and pre-starting checks for oil, fuel, and seat.

Safety Interlock and Starting/Shut Off

Explains the safety interlock system and procedures for starting and shutting off the engine.

MOWING AND PARKING PROCEDURES

Stopping, Parking, and Mowing Tips

Details procedures for stopping, parking, and provides tips for safe mowing.

GENERAL MAINTENANCE

Service Position and Fueling

Explains how to place the unit in service position and safely refuel the tank.

ENGINE AND AIR CLEANER MAINTENANCE

Engine Cooling and Oil Checks

Covers engine cooling system, oil checks, and changing engine oil.

Air Cleaner and Filters

Details maintenance for air cleaner (foam and paper filters) and spark plug.

BELT AND BLADE MAINTENANCE

Belt Replacement Procedures

Provides instructions for replacing rotary mower and drive belts.

MOWER BLADE AND BATTERY CARE

Mower Blade and Pan Maintenance

Covers mower blade sharpening, installation, and mower pan removal.

Battery Safety and Charging

Provides safety warnings and instructions for battery charging.

BATTERY CARE AND JUMP STARTING

Battery First Aid and Terminal Cleaning

Covers battery first aid, terminal cleaning, electrolyte level, and charging.

SEAT, TIRES, AND LUBRICATION

Seat, Tires, and General Lubrication

Details seat care, tire inflation, and general lubrication points and schedule.

MAINTENANCE SCHEDULE

Maintenance Schedule Overview

Presents a chart outlining recommended maintenance tasks and frequencies.

ADJUSTMENTS

Clutch and Brake Adjustments

Explains how to adjust the clutch and brake systems for proper operation.

MOWER ADJUSTMENTS

Mower Belt and Leveling Adjustments

Details mower belt adjustment and how to level the mower pan.

PITCH, HEIGHT, AND ROLLER ADJUSTMENTS

Pitch, Height, and Roller Adjustments

Describes how to adjust mower pitch, cutting height, and anti-scalp rollers.

CLEANING AND STORAGE

Unit Cleaning and Storage Guidelines

Provides instructions for cleaning and storing the unit to prevent rust and damage.

TROUBLE SHOOTING

Troubleshooting Common Problems

Lists common problems, their probable causes, and solutions.

SPECIFICATIONS

Model Specifications

Lists technical specifications for different model numbers.

ATTACHMENTS

Available Attachments

Lists and illustrates available attachments like baggers and blades.

ACCESSORIES

Available Accessories

Lists available accessories such as tire chains, dethatchers, and mulching kits.

WARRANTY INFORMATION

2 Year Limited Warranty Terms

Outlines the terms, conditions, limitations, and exclusions of the limited warranty.

Warranty Limitations and Disclaimers

Details limitations on remedies, damages, and disclaims further warranties.

Related product manuals

Ariens 927046 - RM1028

Ariens IKON-X 52 CARB

48 pages

Ariens IKON-XD Series

Ariens Imperial RM1028 User Manual

Table of Contents

Questions and Answers:

Ariens Imperial RM1028 Specifications

Summary

CONTROLS AND FEATURES

Control Identification

INTRODUCTION

Manual, Service, and Registration

Disclaimer

SAFETY

Safety Symbols, Signal Words, and Practices

OPERATIONAL SAFETY RULES

Unit, Personal, and Maintenance Safety

SPECIFIC SAFETY HAZARDS

Fuel, Exhaust, Slopes, and Battery Hazards

TRANSPORT AND ATTACHMENT SAFETY

Transport, Rolling, and Bagger Safety

OPERATION

Standard Controls and Ignition

Starting Systems and Pedals

Speed Selector and Attachment Clutch

OPERATION DETAILS

Attachment Lift, Parking Brake, and Pre-Start Checks

Safety Interlock and Starting/Shut Off

MOWING AND PARKING PROCEDURES

Stopping, Parking, and Mowing Tips

GENERAL MAINTENANCE

Service Position and Fueling

ENGINE AND AIR CLEANER MAINTENANCE

Engine Cooling and Oil Checks

Air Cleaner and Filters

BELT AND BLADE MAINTENANCE

Belt Replacement Procedures

MOWER BLADE AND BATTERY CARE

Mower Blade and Pan Maintenance

Battery Safety and Charging

BATTERY CARE AND JUMP STARTING

Battery First Aid and Terminal Cleaning

SEAT, TIRES, AND LUBRICATION

Seat, Tires, and General Lubrication

MAINTENANCE SCHEDULE

Maintenance Schedule Overview

ADJUSTMENTS

Clutch and Brake Adjustments

MOWER ADJUSTMENTS

Mower Belt and Leveling Adjustments

PITCH, HEIGHT, AND ROLLER ADJUSTMENTS

Pitch, Height, and Roller Adjustments

CLEANING AND STORAGE

Unit Cleaning and Storage Guidelines

TROUBLE SHOOTING

Troubleshooting Common Problems

SPECIFICATIONS

Model Specifications

ATTACHMENTS

Available Attachments

ACCESSORIES

Available Accessories

WARRANTY INFORMATION

2 Year Limited Warranty Terms

Warranty Limitations and Disclaimers

Related product manuals