24
Preventive Maintenance Schedule
The Tenor is subject to wear and tear, and the following actions must be performed when speci-
fied to ensure that the product remains within its original manufacturing specification.
Note: Product cannot be maintained and serviced while in use with the patient.
Preventive Maintenance Schedule
WARNING
The points on this checklist are the minimum the manufacturer recommends. In some
cases due to heavy use of the product and exposure to aggressive environment, more
frequent inspections shall be carried out. Continuing to use this product without
conducting regular inspections or when a fault is found will seriously compromise the
user and residents’ safety. Local regulations and standards may be higher than the
manufacturers. Preventive maintenance specified in this manual can prevent accidents.
The parts which are entitled ‘Checks to be performed by Qualified Arjo personnel’ have
to be carried out by qualified personnel, using the correct tools and knowledge of proce-
dures. Failure to meet these requirements could result in personal injuries and / or
unsafe product.
Action/Check Before each
use
Every
day
Every
Week
Every
6 months
Every
12 months
CAREGIVER OBLIGATIONS
ARJO SLINGS
Examine the slings, their straps and attachment loops. If any
part of the sling or its straps is frayed or any one of the loops
is damaged, the sling must be withdrawn from use
immediately and replaced with a new sling.
X
Where necessary, after resident use, carry out
decontamination of the sling in accordance with Arjo and
local decontamination regulations
X
Read the Guidelines on the use of your sling.
X
ARJO BATTERY CHARGER
Visually examine the battery charger for loose connectors,
cut wires and damage to the casing. Do not use if found
loose, cut or damaged in any way
X
ARJO TENOR
Make sure the battery is charged before use. If not
adequately charged, replace with a fully charged battery.
X
When necessary, after each resident use, carry out
decontamination of the Arjo Te n o r in accordance with Arjo
Operating Instructions and local regulations.
X
Make sure the battery pack is in a good state of charge.
Charge the battery at the end of each working shift until the
charger indicates full charge.
X
The lifter is fitted with a warning device. When the battery
discharge indicator reaches the red flashing light, the battery
must be charged as soon as possible
X
Make sure all castors rotate freely and the two rear brakes
lock.
X
Make sure the castor-mounting pin is tight on the chassis
and chassis legs and the castor tread is not damaged. Be
sure to remove any fluff, hair or debris from the wheels to
ensure their proper functioning.
X
Check that all external fittings are secure and that all screws
and nuts are tight.
X
To Next Page
Loading...
