Instruction book
1904 0504 83
ϵ
c. Verify that all tubes are secure in their fittings to insure that none might leak or come loose
when the compressor is in operation.
[ 8 S 8 P
>
O <
?
7 < < B
>
: A T
>
B
@
8 9
? >
B A 7 : ; 9 7 A T
?
;
@
8 9 : T
>
; 9 P B 6
?
8 \
>
O < 9 U < : B A
?
R 8
@ > ]
U
>
9 : U
>
@
< S 6
? >
B B <
?
; B ; 9 < 6
> ?
8 : ; < 9 8 9 O
? >
B A 7 : ; 9 O 8 S 8 P
>
: < : U
> @
< S 6
? >
B B <
?
<
?
R ;
? >
W
After inspection, the power can be put to the installed compressor. With the proper power
applied, the rotation of the compressor and the cooling fan can be verified.
Also consult following safety precautions: Safety precautions during operation
and Safety precautions during maintenance.
These precautions apply to machinery processing or consuming air or inert
gas. Processing of any other gas requires additional safety precautions typical
to the application which are not included herein.
Some precautions are general and cover several machine types and
equipment; hence some statements may not apply to your machine.
All responsibility for any damage or injury resulting from neglecting these
precautions, or non observance of the normal caution and care required for
installation, operation, maintenance and repair, even if not expressly stated,
will be disclaimed by the manufacturer.
N
? > @
8 A : ; < 9 B O A
?
; 9 P < 6
> ?
8 : ; < 9
C D
Air hoses shall be of correct size and suitable for the working pressure. Never use frayed
damaged or deteriorated houses. Use only the correct type and size of hose end fittings and
connections. When blowing through a hose or airline, ensure that the open end is held securely.
A free end will whip and may cause injury. Make sure that a hose is fully depressurized before
disconnecting it.
E D
Never play with compressed air. Do not apply it to your skin or direct an air stream at people.
Never use it to clean dirt from clothes. When using it to clean equipment, do so with extreme
caution and use eye protection.
F D
The compressor is not considered as capable of producing air for breathing quality. For
breathing air quality, the compressed air must be adequately purified according to local
legislation and standards.
G D
Never operate the unit at pressures below or in excess of its limit ratings as indicated on the
Principal Data sheet.
Never touch any piping or components of the compressor during operation.
H
D
Persons switching on remotely controlled machines shall take adequate precautions to ensure
that there is no one checking or working on the machine. To this end, a suitable notice shall be
affixed to the remote start equipment.
I D
Never operate the machine when there is a possibility of taking in flammable or toxic fumes,
vapors or particles.
J
D
Keep all bodywork doors shut during operation. The doors may be opened for short periods
only, e.g. to carry out routine checks. Wear ear protectors when opening a door.
K D
On compressor without bodywork, wear ear protection in the vicinity of the machines.
L D
People staying in environments or rooms where the sound pressure level reaches or exceeds
80 dB(A) shall wear ear protectors.
C M D
Periodically check that:
To Next Page
Loading...
Need help?
General
