C300H / C300HI / C300H x4 / C300HI x4
C350H / C350HI / C350H x4 / C350HI x4
107
Parking brake
Oil: Replacing
If the brake pedal lowers excessively, refer to the authorized AUSA dealer for adjusting,
bleeding or replacement of the inner discs.
Releasing the parking brake while the engine is stopped:
- This operation should be carried out following the instructions given in TOWING
THE FORKLIFT in this Operator’s and Safety Manual.
NOTE
The brake that incorporates this machine requires no maintenance. If the
brake pedal lowers excessively, refer to the authorized AUSA dealer for
adjusting, bleeding or replacement of the inner discs.
Service brake
Adjusting (fig. 1)
If the pedal has excessive free play, this can be corrected using the push rod (a) of the
pedal which operates the brake pump. This has a system of nut and locknut. Allow the
push rod to have a free play of between 1 to 1’5 mm (0’04 and 0’06 in.), making sure that
the pump is free of internal pressure.
If, on applying the service brake, the pedal lowers too much it should be adjusted. To do
so, contact an AUSA authorized dealer.
NOTE
The brake that incorporates this machine requires no maintenance. If the brake
pedal lowers excessively, refer to the authorized AUSA dealer for adjusting,
bleeding or replacement of the inner discs.
Brake and inching fluid: Checking the level (fig. 2).
With the forklift parked on a level surface, the level of the brake fluid in the tank should
lie between the marks MIN. and MAX.
If necessary, top up the brake fluid in the tank:
- Unscrew the filler cap and use a funnel to prevent spillage.
- Top up with fluid until the level reaches the MAX. mark.
- Close the filler cap by screwing it on again.
Note: While topping up, do not exceed the MAX. mark.
WARNING
If it becomes necessary to top up the brake fluid frequently, it is possible that the
brake system has a leak. Park the forklift correctly (See the section PARKING
THE FORKLIFT TRUCK) and consult an authorized AUSA dealer.
Brake an inching fluid: Replacing
The replacement of brake fluid or any repair to the brake system should be carried out
by an authorized AUSA dealer.
(fig. 2) (fig. 1)
a
MÁX
MÍN
Periodic
Maintenance
Operations
To Next Page
Loading...
