Bad Boy 2015 Recoil iS User Manual

GENERAL SPECIFICATIONS
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
7
Owner’s Manual
GENERAL SPECIFICATIONS
MODEL: RECOIL iS
TYPE: ELECTRIC OFF ROAD VEHICLE
MODEL YEAR: 2015
Part No: 640370G01
Programmable AC Drive System:
Factory programmable to application
z Solid State variable frequency AC speed controllers z
300 Amp AC Controllers
z Drive-by-wire electronic throttle control z Full torque, reduced speed reverse
z Dash mounted direction selector switch (Forward-Neutral-Reverse) z Sealed Hall effect throttle sensor
z Descent speed control z Full diagnostic capability (Hand held diagnostic unit)
z Full-time regenerative braking z Dash mounted Max Speed/Max Range speed selector switch
Motor:
Battery Charger:
Remote 72 VDC DPI Charger, 120 VAC 60 Hz or optional 230VAC 50Hz unit. (U.L. Certified)
Electrical System:
72 Volt DC, nine, 8 volt deep cycle storage batteries
Drive Train:
Direct motor shaft connected to transaxle pinion shaft
Transaxle:
Differential with reverse helical gears
Brakes:
4-wheel hydraulic disc brakes and Induction motor. Manual parking brake
Body Protection: Front Brush Guard
Performance
Overall Length in cm
Seating Capacity & St
yle 2 Persons - Bench Seat
Overall Width in cm
Curb Weight lb kg
Overall Height in cm
Vehicle load capacity lb kg
Wheel Base in cm
Gross Axle Weight Rating - F lb kg
Gnd Clearance @ Frame in cm
Gross Axle Weight Rating - R lb kg
Gnd Clearance @ Differential in cm
Outside Clearance Circle ft m
Vehicle Power
Speed - Low (Level Ground) mph kph
Power Source 72 Volts DC
Speed - High (Level Ground) mph kph
Motor Type 72 Volts AC
Speed - Reverse mph kph
Horsepower (kW) hp kW
Steering & Suspension
Electrical System 72 Vol
t
Steering Double Ended Rack & Pinion - 3.69 turns to lock
Batteries (Qty, Type) Nine, 8 Volt Deep Cycle
Front Suspension MacPherson Strut
Key or Pedal Start Key Start
Rear Suspension MacPherson Strut
Speed Controller 300 amp
Service Brake 4-Wheel Hydraulic Disc with Motor Regen
Drive Train Motor Shaft Direct Drive
Parking Brake Manual w/controller cut-out
Transaxle Hardened Helical Gears
Front Tires Kenda 25x8-12 Uni-Directional
Direction Selection Dash mounted Forward-Neutral-Reverse
Rear Tires Kenda 25x11-12 U
ni-Directional
Speed Selection Dash mounted Speed/Range switch
Body & Chassis
Rear Axle Ratio
Frame Welded Steel with DuraShield powder coat
Front Axle Ratio
Body & Finish Injection Molded TPO & Automotive Style Paint
Standard Color Matte Black
Cargo Bed 9.7 Cu. Ft. Polyethelyne Bed
Some items shown may be optional equipment
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
Two 72 Volt AC induction motors, solid copper windings. 19 hp (17.3 kW) peak. AC system reads motor speed for accurate speed
control in all conditions. Regenerative braking for maximum economy
Dimensions
17.3
16.0 41
814
426
333
907
178
9.5 24
38
PRODUCT OVERVIEW
112.0 284
52.0 132
76.5 194
12.49:1
12.49:1
24.5
1,795
940
Towing capacity lb kg4541,000
735
2,000
10.0
7.5
16.1
24.5
16.0 25.7
39.4
70.0

Bad Boy 2015 Recoil iS Specifications

General

Brand	Bad Boy
Model	2015 Recoil iS
Category	Offroad Vehicle
Language	English