PERIODIC SERVICE SCHEDULE
Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
47
Owner’s Manual
PERIODIC SERVICE SCHEDULE
PERIODIC SERVICE SCHEDULE
CH - CHECK C&A - CHECK & ADJUST CL - CLEAN R - REPLACE
REMARKS
Before each use
DAILY
250 miles/415 kms
MONTHLY
750 miles/1250 kms
QUARTERLY
1500 miles/2500 kms
SEMI-ANNUAL
3000 miles/5000 kms
ANNUAL
REPLACE AFTER
Tires - pressure, condition of tires & rims CH CH CH CH CH
Hardware - loose or missing CH CH CH CH CH
Overall Vehicle Condition CH CH CH CH CH
Seat Belts - Inspect webbing for cuts, frays or any kind of
damage or wear that could weaken the belt. Check latch
mechanism for proper operation.
CH CH CH CH CH
Batteries - state of charge, condition, loose terminals,
corrosion, hold downs & hardware
CH CL CL CL
Batteries* - check electrolyte level, fill after charging if
required (if plates are exposed before charging, add only
enough water to cover any exposed plates and fill after
charging)
C&A C&A C&A C&A
Brakes - Check fluid level in master cylinder
CH CH CH CH 3000 miles/
5000 kms
Brakes - smooth operation of pedal, stopping distance CH CH CH CH CH
Park Brake - ability to hold on a hill C&A C&A C&A C&A
Accelerator - smooth operation CH CH CH CH CH
Wiring - loose connections, broken or missing insulation CH CH CH CH
Charger Receptacle - inspect and clean receptacle at each
charge
CL CL CL CL
Direction Selector - attachment and mechanism C&A C&A C&A C&A
Steering Assembly - excessive play, loose or missing hard-
ware
CH CH CH CH
Tie Rods - excessive play, bent rods, loose or missing hard-
ware
CH CH CH CH
Front and Rear Axle - oil leakage, noise, loose or missing
hardware
CH CH CH CH
Front and Rear Axle - drain and replace fluid
5000 miles/
8000 kms
Front Suspension - strut oil leakage, excessive play in hubs
or kingpins, worn bushings, loose or missing hardware
CH CH CH CH
Rear Suspension - strut oil leakage, worn bushings, loose or
missing hardware
CH CH CH
Front Wheel Alignment - unusual tire wear C&A C&A C&A
* Use only distilled or purified water that is free from contaminates to fill batteries.
NOTE: Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.