Page 5 - 19
MAINTENANCE
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
5
CAPACITIES AND REPLACEMENT PARTS
The front and rear axles do NOT use the same oil.
Axles - drain & replace fluid R
Rear Suspension - shock oil leakage, worn bushings,
loose or missing hardware
Front Suspension - strut oil leakage, excessive play in
hubs or kingpins, worn bushings, loose or missing
hardware
Front Wheel Alignment - unusual tire wear C&A C&A C&A
Throttle/Governor Linkage - operation & governed
speed
Air Filter Element - check & replace as necessary
Drive Belt - cracks, frayed, excessive wear
REMARKS
before each use
DAILY
WEEKLY
20 hrs
100 miles/160 kms
MONTHLY
60 hrs
300 miles/500 kms
QUARTERLY
125 hrs
600miles/1000 kms
SEMI-ANNUAL
250 hrs
1200miles/2000 kms
ANNUAL
5 YEARS
PAGE
NOTE: Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.
CAPACITIES
Fuel Tank / Fuel
Engine Oil
Front Axle Oil
Rear Axle Oil
Brake Fluid
5.3 gal (20 liters) / 87 Octane Min.
48 oz. synthetic oil 5W30
13.8 oz. 90 wt. gear oil
48 oz. SAE 30 wt. oil
DOT 3
REPLACEMENT PART NUMBERS
Oil Filter
Air Filter
Spark Plug
Starter/Generator Belt
LED Headlight Bulb
Turn Signal Bulb
Tail Light Bulb
See Appendix A
See Appendix A
See Appendix A
p/n 75690G01
p/n 619101
p/n 619102
#1157 p/n 21759G1
To Next Page
Loading...
Need help?
General
