Bajaj CT 110 - Page 33

Periodic Maintenance & Lubrication Chart
29
25. All fasteners tightness C,T C,T C,T C,T C,T C,T C,T C,T
26. Engine foundation silent bushes C C C
27. General lubrication-Clutch lever, L L L L L L L L Use AP grease.
front brake lever.
28. Idle speed / CO% C,A C,A C,A C,A C,A C,A C,A C,A
29. Spoke tightening-Front & Rear C,T C,T C,T C,T C,T C,T C,T C,T
30. SAI, EVAP hoses - Check functionality, C,R C,R C,R C,R C,R C,R C,R C,R Replace if cut / damaged
leakage or any other damage
31. EVAP drain tube cleaning CL CL CL CL CL CL CL CL
*** More frequent cleaning may be required while driving in dusty environment.
C : Check, A : Adjust, CL : Clean, R : Replace, T : Tighten, L : Lubricate
Note : Periodic parts, Oil, Filters, All types of greases, Cleaning agents, Cables, Wear & tear parts, Rubber ‘O’ rings / oil
seals / pipes, Gaskets to be replaced as per Periodic Maintenance and Lubrication Chart are mandatory and the same
are chargeable to customer.
RECOMMENDED FREQUENCY
Servicing
st
1 Free
500
~
750
nd
2 Free
4500
~
5000
rd
3 Free
9500
~
10000
Kms
Every
5000 Km after
Previous Service
 Tick in the box  after replacing the periodic parts.
Sr.
No.
Operation Remarks