Bauer Compressors MAXI VERTICUS - Page 11

MVT26
October 2003 Section 1 Page 9
Figure 3.1-36 K180 1st Stage Auxiliary Cooler......................................................................................................................... 55
Figure 3.1-37 Lubricating System Assembly............................................................................................................................. 56
Figure 3.1-38 Lubricating System.............................................................................................................................................. 57
Figure 3.2-1 4 Stage Automatic Condensate Drain System..................................................................................................... 58
Figure 3.2-2 ACD Operation Diagrams ...................................................................................................................................59
Figure 3.2-3 ACD Timer .......................................................................................................................................................... 61
Figure 3.2-4 4 Stage ACD System ...........................................................................................................................................62
Figure 3.2-5 ACD Manifold and Valves .................................................................................................................................. 63
Figure 3.2-6 3rd Stage Condensate Drain Valve......................................................................................................................64
Figure 3.2-7 Oil and Water Separator Condensate Drain Valve ..............................................................................................66
No. Title Page
Section 4: Scheduling Maintenance
There are no Figures in this Section
No. Title Page
Section 4: Purification Systems
Figure 4.1-1 Cartridge Safety Venting ..................................................................................................................................... 73
Figure 4.1-2 Compressor Unit Identification Plate ..................................................................................................................73
Figure 4.1-3 Purification System Dataplate (typical)............................................................................................................... 74
Figure 4.1-4 Cartridge Installation Dataplate (typical) ............................................................................................................ 74
Figure 4.1-5 Correction Factor for Cartridge Operating Hours ............................................................................................... 76
Figure 4.1-6 Example Record of Adjusted Operating Hours ................................................................................................... 76
Figure 4.2-1 P5 Purification System ........................................................................................................................................ 78
Figure 4.2-2 Oil and Water Separator ...................................................................................................................................... 81
Figure 4.2-3 Cartridge Replacement ....................................................................................................................................... 82
Figure 4.2-4 Oil and Water Separator ..................................................................................................................................... 83
Figure 4.2-5 27” Chamber Assembly....................................................................................................................................... 84
Figure 4.2-6 Securus
®
Electronic Air Purification Monitoring System ..................................................................................86
No. Title Page
Section 5: Compressor Unit Drive
Figure 5.1-1 Vertical Motor Mount (typical) ...........................................................................................................................88
No. Title Page
Section 6: Miscellaneous
Figure 6.1-1 Pressure Maintaining Valve................................................................................................................................. 90
Figure 6.1-2 Safety Valves....................................................................................................................................................... 91
Figure 6.2-1 Pressure Switch.................................................................................................................................................... 92
Figure 6.2-2 Electrical Parts..................................................................................................................................................... 94
Figure 6.2-3 Indicators ............................................................................................................................................................. 95