S.p.A. BT 2001 R
19
PERIOD PART OPERATION
During first 50 hours (running in) • Diesel Engine
• Wheels
• Check the oil level
• Check that wheel nuts are tight
After first 50 hours (checking) • Diesel Engine
• Diesel Engine
• Oil filter
• Wheels
• Tyres
• See the Manual
• Change oil in the motor
• Change the filter
• Check that wheel nuts are tight
• Check the pressure
Every 10 hours (daily) • Diesel Engine
• Air filter
• Check the oil level
• Check the oil level
Every 50 hours (weekly) • Gear box and Differential
• Tractor
• Lubricating Points
• Tyres
• Check the oil level
Clean mud and dirt from tractor
• Lubricate
• Check pressure
Every 125 hours • Diesel Engine • Change engine oil
Every 250 hours (or once every
year)
• Engine Oil filter
• Fuel filter
• Air filter
• Fixing screws
• Change the filter
• Change the filter
• Change oil and clean the filter
• Check that they are tight
Every 500 hours (or once every 2
years)
• Change gear, differential
• Fuel tank
• Change oil
• Clean and drain any water
NOTE: See the table below for lubricant information, type and quantity.
COMPONANT OIL TYPE QUANTITY
Oil mod. MD151 MULTIGRADE 15W/40 1,8 litres
Fuel Tank 8 litres
Gear box / Differential AGIP ROTRA MPS SAE 80/90 12 litres
Grease Points (lithium grease) G.P. GREASE LP2 Q.B.
After the first 50 hours, carry out the following
operations:
ENGINE
Ø Follow the instructions in the relative maintenance
and use manual.
Every 10 hours (every day) carry out the following
maintenance operations:
Ø Check the oil level, as instructed in the maintenance
and use manual.
Filter
Ø For machines equipped with an oil bath filter, clean
the filter every 50 hours: take out the cartridge, clean
with oil and dry. Put new oil in the filter. Use the same
oil as used in the engine.
Every 125 hours carry on the following
maintenance operations:
ENGINE
Ø Change the engine oil and clean the internal filter
(see Advice). Follow the instructions contained in the
maintenance and use manual for the engine.
Every 250 hours carry out the following
maintenance operations:
Air filter
Change the oil in the air filter, following the instruction
contained in the engine manual.
Fuel filter
Change the filter, following the instructions contained in
the engine manual.
Engine oil filter
Change the filter
Every 500 hours and every 2 years carry out
the following maintenance operations:
Diesel tank
Ø Drain water and clean. Follow the instruction
container in the relative use and maintenance manual.
Gear box and Differential
Ø Check the level every 50 hours with the dipstick
fitted to the cap (Ref.4 Fig.6) found between the seat
and the steering gear.
Ø Use AGIP ROTRA MP SAE 80W/90 oil.
Ø Change the oil every 500 hours. Quantity: approx. 12
litres.
To Next Page
Loading...