REFERENCE INFORMATION
SAFETY NOTICE
SAFETY NOTICE
Before working on any part of the outboard, read the SAFETY section at the end of this manual.
This publication is written for qualified, factory-
trained technicians who are already familiar with
the use of Evinrude/Johnson Special Tools. The
included information is not a substitute for work
experience. It is an organized guide for reference,
repair, and/or maintenance.
The following symbols and/or signal words
may be used in this document:
Indicates an instruction which, if
not followed, could severely damage engine
components or other property.
These safety alert signal words mean:
ATTENTION!
BECOME ALERT!
YOUR SAFETY IS INVOLVED!
IMPORTANT: Identifies information that con-
trols correct assembly and operation of the prod-
uct.
DO NOT perform any work until you have read
and understood these instructions completely.
Torque wrench tightening specifications must
strictly be adhered to.
Should removal of any locking fastener (lock tabs,
locknuts, or patch screws) be required, always
replace with a new one.
When replacement parts are required, use Evin-
rude/Johnson Genuine Parts or parts with equiva-
lent characteristics, including type, strength and
material. Use of substandard parts could result in
injury or product malfunction.
Always wear EYE PROTECTION AND APPRO-
PRIATE GLOVES when using power tools.
Unless otherwise specified, engine must be OFF
when performing this work.
Always be aware of parts that can move, such as
flywheels, propellers, etc.
Some components may be HOT. Always wait for
engine to cool down before performing work.
If you use procedures or service tools that are not
recommended in this manual, YOU ALONE must
decide if your actions might injure people or dam-
age the outboard.
This document may be translated into other lan-
guages. In the event of any discrepancy, the Eng-
lish version shall prevail.
A DANGER
Indicates a hazardous situation which, if
not avoided, will result in death or serious
injury.
A WARNING
Indicates a hazardous situation which, if
not avoided, could result in death or seri-
ous injury
A CAUTION
Indicates a hazardous situation which, if
not avoided, could result in minor or mod-
erate personal injury.
To Next Page
Loading...
Need help?
General
