Carrier 38HQ 18-24 - Start-Up Procedures; Indoor Fan Operation Verification; System Operation Observation

14
START-UP
A. Check Indoor Fan Operation
Under Ceiling Fan Coil Units
SELECT FAN MODE, THEN INITIATE TEST SEQUENCE. DOES THE FAN COIL UNIT
START AT LOW SPEED, THEN SHIFT TO MEDIUM SPEED, AND THEN SHIFT TO HIGH
SPEED? (Y/N) _____
Cassette Fan Coil Units
POSITION SELECTOR SWITCH AT SUBBASE IN EACH FAN SPEED SETTING IN
SEQUENCE. DOES THE FAN COIL UNIT CHANGE SPEEDS PER SWITCH SETTING?
(Y/N) _____
B. Start System Operation at the Fan Coil Unit
SELECT COOLING MODE AND ADJUST SET POINT TO BE BELOW CURRENT ROOM
TEMPERATURE. OBSERVE OPERATION OF OUTDOOR CONDENSING UNIT:
DOES COMPRESSOR START (AFTER INITIAL TIME DELAY) AND RUN? (Y/N) _____
DOES OUTDOOR FAN RUN OR CYCLE ACCORDING TO SPACE REQUIREMENTS?
(Y/N) _____
DE-SELECT COOLING MODE AT INDOOR FAN COIL UNIT, AND RECORD ALL
INFORMATION BELOW:
AFTER AT LEAST 15 MINUTES RUNNING TIME, RECORD THE MEASUREMENTS
BELOW.
COMPRESSOR AMPS (L1/L2/L3) __________
OIL PRESSURE __________
VAPOR LINE PRESSURE __________
VAPOR LINE TEMP __________
DISCHARGE PRESSURE __________
DISCHARGE LINE TEMP __________
ENTERING OUTDOOR-AIR TEMP __________
LEAVING OUTDOOR-AIR TEMP __________
FAN COIL UNIT
INDOOR ENTERING-AIR dB (dry bulb) TEMP __________
INDOOR ENTERING-AIR WB (wet bulb) TEMP __________
INDOOR LEAVING-AIR dB TEMP __________
INDOOR LEAVING-AIR WB TEMP __________