Carrier AquaEdge 19XR series - Page 189

189
APPENDIX C — MAINTENANCE SUMMARY AND LOG SHEETS
19XR,XRV Monthly Maintenance Log
NOTE: Equipment failures caused by lack of adherence to the Maintenance Interval Requirements are not covered under warranty.
MONTH 123456789101112
DATE / / / / / / / / / / / / / / / / / / / / / / / /
OPERATOR
UNIT SECTION ACTION UNIT ENTRY
COMPRESSOR
Change Oil Charge yes/no Change Oil Filter yes/no Send Oil Sample Out for Analysis yes/no Leak Test ppm Inspect Compressor Rotors yes/no Bearing Inspection yes/no
COOLER
Inspect and Clean Cooler Tubes yes/no Inspect Relief Valves yes/no Leak Test PPM Record Water Pressure Differential (PSI) PSI Inspect Water Pumps yes/no Eddy Current Test yes/no
CONDENSER
Leak Test PPM Inspect and Clean Condenser Tubes yes/no Record Water Pressure Differential (PSI) PSI Inspect Water Pumps and Cooling Tower yes/no Inspect Relief Valves yes/no Replace Refrigerant Filter Drier yes/no Inspect Float Valve and Strainer yes/no Eddy Current Test yes/no
CONTROLS
General Cleaning and Tightening Connections yes/no Check Pressure Transducers yes/no Confirm Accuracy of Thermistors yes/no Perform Automated Controls Test yes/no
STARTER
General Tightening and Cleaning Connections yes/no Change VFD Refriferant Strainer yes/no
OIL RECLAIM
Inspect Oil Sump Strainer yes/no Inspect Oil Sump Heater yes/no