To Next PageTo Next PageWhat to do if flames blow out on Char-Broil Grill?
If flames are blowing out on your Char-Broil Grill, it could be due to high or gusting winds. Turn the front of the grill to face the wind or increase the flame height. Another reason could be low LP gas, so refill the LP cylinder. Also, refer to the troubleshooting step for a sudden drop in gas flow.
How do you manually light Char-Broil TRU-Infrared 463251012?
If the burner(s) on your Char-Broil Grill will not match light, use a long-stem match (fireplace match). Also, see the “Match-Lighting” section of Use and Care.
How to prevent flare-ups on Char-Broil Grill?
Flare-ups on your Char-Broil Grill can happen due to grease buildup. To solve this, clean the burners and the inside of the grill/firebox. Another cause can be excessive fat in the meat, so trim the fat before grilling. Also, excessive cooking temperature can cause flare-ups, so adjust the temperature accordingly.
Why is the flame so low on my Char-Broil TRU-Infrared 463251012 Grill?
A sudden drop in gas flow or low flame in your Char-Broil Grill might be because you're out of gas. Check the LP cylinder for gas. If that's not the issue, turn off the knobs, wait 30 seconds, and light the grill. If the flames are still low, turn off the knobs and the LP cylinder valve, disconnect the regulator, reconnect it, perform a leak test, turn on the LP cylinder valve, wait 30 seconds, and then light the grill. Another potential cause is a loose connection; turn off the knobs and LP cylinder valve, disconnect the coupling nut from the cylinder, reconnect it, and try again.
How to fix flashback in Char-Broil TRU-Infrared 463251012?
If you experience a flashback (fire in the burner tubes) in your Char-Broil Grill, it is likely that the burner and/or burner tubes are blocked. Turn the knobs to the OFF position and clean the burner and/or burner tubes. Refer to the burner cleaning section of the Use and Care guide for detailed instructions.
What to do for a grease fire in Char-Broil TRU-Infrared 463251012?
If you're experiencing a persistent grease fire in your Char-Broil Grill, it's likely due to grease trapped by food buildup around the burner system. Turn the knobs to the OFF position and turn off the gas at the LP cylinder. Leave the lid in position and let the fire burn out. After the grill cools, remove and clean all parts.
Why are the sparks weak on my Char-Broil Grill?
If sparks are present but not at all electrodes or not at full strength on your Char-Broil Grill, remove and reconnect all output connections at the module and electrodes. If possible, observe the grill in a dark location to check for arcing between output wires and the grill frame. Also, replace the battery with a new alkaline battery if it's weak. Use a paper towel to remove any moisture from the electrodes. Finally, replace any cracked or broken electrodes.
Why can't I fill my Char-Broil TRU-Infrared 463251012 LP cylinder?
If you are unable to fill your LP cylinder, it may be because some dealers have older fill nozzles with worn threads. These worn nozzles might not have enough “bite” to engage the valve. Try a second LP dealer.
Why won't the LEDs light up on my Char-Broil Grill?
If no LEDs illuminate on your Char-Broil Grill, the battery may be dead. Replace the batteries.
Why does the timer not work on my Char-Broil Grill?
If the timer on your Char-Broil Grill does not work (and the green light does not flash), the battery may be dead. Replace the batteries. Also, the batteries may be installed incorrectly, so install the batteries correctly. Finally, the knob position may not have started the Clean Cycle, so push the knob in to start the clean cycle (the green LED should begin to flash).
General| Type | Gas Grill |
|---|---|
| Fuel Type | Propane |
| Cooking System | TRU-Infrared |
| Total Cooking Area | 450 sq. in. |
| Burners | 3 |
| Burner Material | Stainless Steel |
| Infrared Technology | Yes |
| Side Burner | No |
| Cooking Area | 450 sq. in. |
| Grate Material | Porcelain-coated Cast Iron |
| Material | Steel |
| BTU Output | 24000 BTU |
| Ignition Type | Electronic |
Details LP gas properties, filling, leak testing, and regulator connection.
Crucial safety rules for grill operation, placement, and fire prevention.
Instructions for attaching casters and side panels to the bottom shelf.
Steps for attaching lower back panel and center cart divider.
Instructions for installing cabinet shelf, upper back panel, and front brace.
Positioning the grill head and connecting the ignition system.
Attaching side shelves, control panels, side burner lid, and doors.
