Home
Cleveland
Electric Steamer
steamcraft 21-CET-8
Cleveland steamcraft 21-CET-8 User Manual
5
of 1
of 1 rating
139 pages
Give review
Manual
Specs
To Next Page
To Next Page
Loading...
Cleveland Range
SteamCraft
3.1
®
COUNTER TYPE
CONVECTION STEAMER
SERVICE
MANUAL
Model 21
-
CET
-
8
Printed
12/90
Cts
-
01
2
Table of Contents
Default Chapter
4
Table of Contents
4
Chapter 1. Product Identification
10
Model Number
10
Serial Number
10
Product Information Plate
10
Chapter 2. Installation Instructions
11
Introduction
11
Installation Policies
11
Installation Overview
12
Preparation for Installation
14
Electric Power Requirements
14
Water Quality Requirements
14
Water Supply System
15
Selecting the Operating Location
15
Installation Instructions
17
Unpacking and Inspection
17
Shipping Damage Instructions
18
Position and Level the Steam Craft 3.1
18
Leg Mounting and Leveling
18
Surface Mounting and Leveling
19
Stand Mounting and Leveling
20
Install Slide Racks
22
Install the Free Air Vented Drain Lines
22
Connect Drain Line
24
Install Electric Power Lines
24
Connect Electrical Line
25
Install Water Supply Lines
26
Connect Water Supply Lines
28
General Connection Requirements
29
Untreated Water Connection (Without Steamergard)
29
Treated Water Connection (with Steamergard)
29
Testing Water Supply Lines
29
Final Setup and Checkout
30
Setup and Blowdown Inspection - All Steamcraft 3.1'S
30
Operating Tests - Key Pad Control Panel
32
Operating Tests - Dial Timer Control Panel
34
Chapter 3. Operation
37
Introduction
37
Operational Safety
37
Control Panels
38
Key Pad Control Panel Summary
39
Cooking Operations- Keypad Control Panel
40
Manual and Timed Modes
40
Main Power Switch
40
Power on (Automatic Fill)
42
Inspect the Cooking Compartment
42
Preheating the Steamcraft 3.1
43
Operating Procedure - Timed Mode
44
Operating Procedure - Manual Mode
47
Manual Timer
47
Temperature Compensation
47
Manual Cooking Procedure
48
Preheating the Steamcraft
48
Printed 12/90
48
Operating Procedure - Timed Mode
56
Shut down and Cleanin G (at End of Day or Shift)
61
Chapter 4. Preventative Maintenance and Troubleshooting
63
Introduction
63
Maintenance Records
63
Daily Mainentance
63
Clean Steamcraft 3.1
63
Weekly Maintenance
63
Monthly Maintenance
64
Yearly Maintenance
67
Troubleshooting Notes
69
Chapter 5. Electrical System
70
Introduction
70
Figures and Illustrations
70
Steamcraft 3.1 Electrical Circuits
70
High Voltage Circuit
70
120 VAC Circuit
70
Timer Circuits
71
Circuit Operation
71
MANUAL Mode Circuit Operation
71
TIMED Mode Circuit Operation
74
Electronic Key Pad Timer Units
75
Mechanical Dial Timer Unit
75
Shutdown, Steam Generator Blowdown,And Float Cylinder Rinse
75
Electrical Circuit Components
77
Heater Element (4, Figure 6-9)
77
Terminal Block (4, Figure 6-7)
77
Dryer Element (7, Figure 6-8)
78
Fuses (8, Figure 6-7)
78
ON/OFF Switch (10, Figure 6-5)
78
Relay
79
TIMED/MANUAL Switch (11, Figure 6-5)
79
3-Minute Timer (14, Figure 6-5)
80
Drain Solenoid Valve (4, Figure 6-12)
80
Fill Solenoid Valve (1, Figure 6-11)
80
Rinse Solenoid Valve (1, Figure 6-11)
80
Condenser Solenoid Valve (1, Figure 6-11)
81
Electronic Key Pad Timer (3, Figure 6-5)
81
Timer
81
3-Second Timer and Buzzer (Mechanical Timer Units Only)(11, 15, Figure 6-6)
82
Compartment Thermal Switch (Electronic Key Pad Units Only)(17, Figure 6-5)
82
Float Assembly (Figure 6-10)
82
High Temperature Limit Switch (1, Figure 6-9)
82
Mechanical Timer (3, Figure 6-6)
82
Component Testing Guide Introduction
84
Nominal Voltage
84
Fundamental Component Testing
84
Visual Check
84
Fuses
85
Connection Points and Wiring
85
Solenoid Valves
85
Timers
86
Thermostatic Snap Switches
86
Heater Element
87
Resistance Measurements
87
Insulation Resistance Measurements
87
Voltage Measurements
87
Component Test Procedures
88
Fuses
88
Transformer
89
ON/OFF Switch
90
Relay K1
90
Fill Solenoid Valve
91
3-Minute Timer
92
Drain Solenoid Valve
93
Rinse Solenoid Valve
94
Condenser Solenoid Valve
95
TIMED/MANUAL Switch
96
High Temperature Limit Switch
97
Electronic Key Pad Timer
97
Compartment Thermal Switch (Key Pad Timer Units Only)
99
Mechanical Timer
100
Heater Contactor
101
Heater and Dryer Elements
102
Float Assembly
103
3-Second Timer and Buzzer (Mechanical Timer Units Only)
106
Chapter 6. Illustrated Parts Lists
108
Introduction
108
Parts Differences Among Steamcraft 3.1 Steamers
108
Electrical Schematics and Wiring Diagrams
108
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Cleveland steamcraft 21-CET-8 and is the answer not in the manual?
Ask a question
Cleveland steamcraft 21-CET-8 Specifications
General
Brand
Cleveland
Model
steamcraft 21-CET-8
Category
Electric Steamer
Language
English
Related product manuals
Cleveland SteamCraft 10
216 pages
Cleveland SteamChef 22CET3.1
29 pages
Cleveland 24/36CGM
23 pages
Cleveland 24CGA10.2
30 pages
Cleveland 24-CEA-10
216 pages
Need help?
General
To Next Page
