Coleman FC9M060B12UP11 - User Manual

TECHNICAL GUIDE
Echelon
MODELS: FC9M*UP
GAS-FIRED
CONDENSING / HIGH EFFICIENCY
UPFLOW MODULATING FURNACES
NATURAL GAS
60 - 120 MBH INPUT
Due to continuous product improvement, specifications
are subject to change without notice.
Visit us on the web at www.york.com for the most
up-to-date technical information.
Additional rating information can be found at
www.gamanet.org.
EFFICIENCY
RATING
CERTIFIED
ISO 9001
Certified Quality
Management System
259720-CTG-B-0108
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
DESCRIPTION
These Category IV, highly efficient, compact, condensing
type furnaces are designed for residential and commercial
installations in a basement, closet, alcove, recreation room or
garage where the ambient temperature is above 32°F, or
higher. They may be either side wall or thru-roof vented using
approved plastic type combustion air and vent piping. All
units are factory assembled, wired and tested to assure
dependable and economical installation and operation.
WARRANTY
Lifetime limited warranty on both heat exchangers to the orig-
inal purchaser; a 20-year limited warranty from original instal-
lation date to subsequent purchaser.
10-year warranty on the heat exchanger in commercial appli-
cations.
5-year limited parts warranty.
FEATURES
• Modulating heating operation includes:
- Modulating gas valve
- Modulating inducer operation
• Provides increased comfort level & very quiet unit opera-
tion
• Compact, easy to install, ideal height 40" cabinet
• Blower-off delay for cooling SEER improvement.
• Easy to connect power/control wiring.
• Built-in, high level self diagnostics with fault code display.
• Low unit amp requirement for easy replacement applica-
tion.
• Integrated control module for reliable, economical opera-
tion.
• May be installed as either two-pipe (direct vent) or single
pipe vent (using indoor combustion air)
• Top intake & vent connection allows installation in narrow
locations.
• Electronic Hot Surface Ignition saves fuel cost with
increased dependability and reliability.
• Induced combustion system with inshot main burners for
quiet, efficient operation.
• No special vent termination kit required.
• 100% shut off main gas valve for extra safety.
• PSC -four speed, direct drive motor with large, quiet
blower.
• 24V, 40 VA control transformer and blower relay supplied
for add-on cooling.
• Hi-tech tubular aluminized steel primary heat exchanger.
• Secondary (condensing) heat exchanger of 29-4C high-
grade stainless steel.
• Solid removable bottom panel allows easy application.
• Easy access from front of unit for cleaning, maintenance or
service.
• Protection from intake, exhaust or condensate blockage.
• Insulated blower compartment for quiet operation.

Summary

Coleman Echelon Furnace Technical Guide

Product Description and Warranty

Summarizes furnace type, efficiency, and warranty terms.

Key Furnace Features

Lists modulating operation, compact design, and advanced diagnostics.

Furnace Dimensions and Cabinet Sizes

Dimensional Drawings and Specifications

Illustrates furnace measurements and connection points.

Model Dimension Data

Table detailing cabinet dimensions for various models.

Electrical and Performance Data

Performance Specifications Table

Details electrical specs, performance metrics, and AFUE for models.

Thermostat Wiring: AC 11 A

Single Stage AC with Modulating Furnace

Wiring diagram for a single-stage AC and modulating furnace.

Thermostat Wiring: AC 11 B

Single Stage AC with Modulating Furnace

Wiring diagram for a single-stage AC and modulating furnace.

Thermostat Wiring: AC 11 C

Single Stage AC with Modulating Furnace

Wiring diagram for single-stage AC and modulating furnace.

Thermostat Wiring: AC 11 D

Single Stage AC with Modulating Furnace

Wiring diagram for a single-stage AC and modulating furnace.

Thermostat Wiring: HP 17 A

Single Stage Heat Pump with Modulating Furnace

Wiring diagram for a single-stage heat pump and modulating furnace.

Blower Performance Data

Cooling Airflow Performance

Tables showing airflow capacity at various static pressures.

Filter Pressure Drop Values

Data on pressure drop for different filter types.

System Airflow and Installation

Filter Pressure Drop Calculation Method

Steps to determine system airflow with filters.

Clearances, Accessories, and Thermostats

Details installation clearances and available accessories.

Coleman FC9M060B12UP11 Specifications

General

Brand	Coleman
Model	FC9M060B12UP11
Category	Furnace
Language	English