Coleman FC9M100C16UP11 - User Manual

TECHNICAL GUIDE
Echelon
MODELS: FC9M*UP
GAS-FIRED
CONDENSING / HIGH EFFICIENCY
UPFLOW MODULATING FURNACES
NATURAL GAS
60 - 120 MBH INPUT
Due to continuous product improvement, specifications
are subject to change without notice.
Visit us on the web at www.york.com for the most
up-to-date technical information.
Additional rating information can be found at
www.gamanet.org.
EFFICIENCY
RATING
CERTIFIED
ISO 9001
Certified Quality
Management System
259720-CTG-B-0108
FOR DISTRIBUTION USE ONLY - NOT TO BE USED AT POINT OF RETAIL SALE
DESCRIPTION
These Category IV, highly efficient, compact, condensing
type furnaces are designed for residential and commercial
installations in a basement, closet, alcove, recreation room or
garage where the ambient temperature is above 32°F, or
higher. They may be either side wall or thru-roof vented using
approved plastic type combustion air and vent piping. All
units are factory assembled, wired and tested to assure
dependable and economical installation and operation.
WARRANTY
Lifetime limited warranty on both heat exchangers to the orig-
inal purchaser; a 20-year limited warranty from original instal-
lation date to subsequent purchaser.
10-year warranty on the heat exchanger in commercial appli-
cations.
5-year limited parts warranty.
FEATURES
• Modulating heating operation includes:
- Modulating gas valve
- Modulating inducer operation
• Provides increased comfort level & very quiet unit opera-
tion
• Compact, easy to install, ideal height 40" cabinet
• Blower-off delay for cooling SEER improvement.
• Easy to connect power/control wiring.
• Built-in, high level self diagnostics with fault code display.
• Low unit amp requirement for easy replacement applica-
tion.
• Integrated control module for reliable, economical opera-
tion.
• May be installed as either two-pipe (direct vent) or single
pipe vent (using indoor combustion air)
• Top intake & vent connection allows installation in narrow
locations.
• Electronic Hot Surface Ignition saves fuel cost with
increased dependability and reliability.
• Induced combustion system with inshot main burners for
quiet, efficient operation.
• No special vent termination kit required.
• 100% shut off main gas valve for extra safety.
• PSC -four speed, direct drive motor with large, quiet
blower.
• 24V, 40 VA control transformer and blower relay supplied
for add-on cooling.
• Hi-tech tubular aluminized steel primary heat exchanger.
• Secondary (condensing) heat exchanger of 29-4C high-
grade stainless steel.
• Solid removable bottom panel allows easy application.
• Easy access from front of unit for cleaning, maintenance or
service.
• Protection from intake, exhaust or condensate blockage.
• Insulated blower compartment for quiet operation.

Summary

Product Description

Category IV Condensing Furnace

Highly efficient, compact, condensing furnaces for residential and commercial installations.

Warranty Information

Heat Exchanger Warranty

Lifetime limited warranty on heat exchangers for original purchaser.

Commercial Applications Warranty

10-year warranty on heat exchanger in commercial applications.

Limited Parts Warranty

5-year limited warranty on parts.

Dimensions

Electrical and Performance Data

Blower Performance - Cooling

Cooling Airflow - Bottom or Side Return

Blower performance for cooling with bottom or one side return.

Cooling Airflow - Two Side or Bottom;Side Return

Blower performance for cooling with two side or bottom/side return.

Filter Performance Data

Filter Pressure Drop

Typical pressure drop values for various filter types and sizes.

System Airflow Calculation

Applying Filter Pressure Drop

Steps and example for calculating system airflow considering filter pressure drop.

Unit Clearances

Accessories

Coleman FC9M100C16UP11 Specifications

General

Model Number	FC9M100C16UP11
Brand	Coleman
Category	Furnace
Fuel Type	Gas
Heating Capacity	100, 000 BTU
Input BTU	100, 000 BTU
Efficiency Rating	96%
AFUE	96%
Blower Motor	Variable Speed
Vent Type	Direct Vent
Stages	Two-Stage
Ignition Type	Hot Surface Ignition
Warranty	10-Year Parts Limited Warranty; Lifetime Heat Exchanger Warranty