NOTICE: The wheel may be bent if not torqued in a crossing pattern. This will cause the wheel to wobble.
5.6 CLEANING
Wash underside to remove all dirt and debris. Do not direct high pressure water at the controller, speed switches, or
tops of the batteries.
Wash body and seat with a mild detergent. Do not use abrasives (bodies are painted).
5.7 LUBRICATION
Every 6 months apply light oil to the rear body hinges.
Semi-annually grease the vehicle chassis. There are seven fittings: three on each side of the front suspension and
one on the brake pedal pivot. Use a high quality grease. Remove the weight from the front suspension before
lubricating to ensure proper grease distribution.
The differential should be checked periodically for signs of leakage. Contact your Columbia Dealer for fluid
replacement.
5.8 MAINTENANCE SCHEDULE - OWNER/OPERATOR
Item Operation Weekly Monthly Semi-Annual
Lug nuts tight.
*
Tires
Check tire pressure, wear, damage. dented rims.
*
Check electrolyte level, clean battery terminals and
cases.
*
Apply equalization charge to the battery pack.
*
Electrical
Check the general condition of the electrical system
(connections, frayed/broken cables).
*
Brakes
Check pedal & park brake operation.
*
Inspect for loose hardware (bolts & nuts).
*
Clean body and seats, Wash as needed.
*
Body and Frame
Wash engine/motor compartment and
undercarriage.
*
Visual check for differential leak.
*
Lube
Oil movement points (body hinges, brake
mechanisms and linkage, leaf spring bushings).
*
Add water per Section 4.10.
*
Check condition of tubing, couplers. Secure & leak
free.
*
Single Point Watering
System – For non-
sealed batteries
Clean filter screen.
*
2012 Summit
5-2
To Next Page
Loading...
