5 - 13
MAINTENANCE
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
5
PERIODIC SERVICE SCHEDULE
- CHECK C&A - CHECK & ADJUST CL - CLEAN R - REPLACE
REMARKS
before each use
DAILY
250 miles/415 kms
MONTHLY
750 miles/1250 kms
QUARTERLY
1500miles/2500 kms
SEMI-ANNUAL
3000miles/5000 kms
ANNUAL
REPLACE AFTER
Tires - pressure, condition of tires and rims
Hardware - loose or missing
Reverse Warning Indicator
Overall Vehicle Condition
Batteries - state of charge, condition, loose terminals, corro-
sion, hold down and hardware
CL CL CL CL
Batteries* - check electrolyte level, fill after charging if required
(if plates are exposed before charging add only enough water
to cover any exposed plates and fill after charging)
C&A C&A C&A C&A
Brakes - check fluid level in master cylinder
3000 mi/5000 km
Brakes - smooth operation of pedal, stopping distance
Brakes - aggressive stop test, does brake hold on a hill
PPPP
Accelerator - smooth operation
Wiring - loose connections, broken or missing insulation
Charger Receptacle - clean connections
CL CL CL CL
Steering Assembly - excessive play, loose or missing hardware
Tie Rods - excessive play, bent rods, loose or missing hard-
ware
Rear Axle - oil leakage, noise, loose or missing hardware
Rear Axle - drain and replace fluid
5000 mi/8000 km
Front Suspension - strut oil leakage, excessive play in hubs or
kingpins, worn bushings, loose or missing hardware
Front Wheel Alignment - unusual tire wear
C&A C&A C&A
Rear Suspension - shock oil leakage, worn bushings, loose or
missing hardware
*Use only distilled or purified water that is free of contaminants to fill batteries.
To Next Page
Loading...
