DAF LF45 - Page Date

EXPLANATORY NOTES ON THE MAINTENANCE ACTIVITIES
2
©
200515
Contents
5
ΛΦ45/55 series
3.38 Checking greased wheel hubs for leaks . . . . . . . . . . . . . . . . . . . . . . . . . . 3-32 . . . . 200515
3.39 Checking the shock absorbers for attachment and leaks . . . . . . . . . . . . . 3-33 . . . . 200515
3.40 Checking the condition and attachments of spring leaves, spring clamps
and U-bolts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-33 . . . . 200515
3.41 Checking the hinge points and axle suspension fastening (air suspension) 3-34 . . . . 200515
3.42 Checking the air suspension bellows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-35 . . . . 200515
3.43 Adjusting the crown wheel guide bolt . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-36 . . . . 200515
3.44 Inspecting the rear axle wheel bearing play . . . . . . . . . . . . . . . . . . . . . . . 3-37 . . . . 200515
3.45 Checking the clamp of the drive shaft universal joint. . . . . . . . . . . . . . . . . 3-38 . . . . 200515
4. REMOVAL AND INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1 . . . . . 200515
Cab and electrical system
4.1 Removal and installation, interior filter element. . . . . . . . . . . . . . . . . . . . . 4-1 . . . . . 200515
Engine, cooling system and fuel system
4.2 Removal and installation, air filter element . . . . . . . . . . . . . . . . . . . . . . . . 4-2 . . . . . 200515
4.3 Removal and installation, lubricating oil filter. . . . . . . . . . . . . . . . . . . . . . . 4-3 . . . . . 200515
4.4 Removal and installation, fuel fine filter . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 . . . . . 200515
4.5 Removal and installation, fuel prefilter/water separator. . . . . . . . . . . . . . . 4-5 . . . . . 200515
4.6 Removal and installation, valve cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6 . . . . . 200515
Steering gear and brake system
4.7 Removal and installation, air dryer filter element. . . . . . . . . . . . . . . . . . . . 4-7 . . . . . 200515
4.8 Removal and installation, filter element in the reservoir of the RAS-EC
steering gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-9 . . . . . 200515
4.9 Removal and installation, high-pressure filter of the RAS-EC steering
gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-10 . . . . 200515
4.10 Removal and installation, F36/F48 front axle wheel hub . . . . . . . . . . . . . . 4-11 . . . . 200515
4.11 Removal and installation, F36/F48 front axle hub seal . . . . . . . . . . . . . . . 4-15 . . . . 200515
Drive and chassis
4.12 Removal and installation, automatic gearbox oil filters . . . . . . . . . . . . . . . 4-16 . . . . 200515
5. DRAINING AND FILLING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 . . . . . 200515
Cab and electrical system
5.1 Topping up battery fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 . . . . . 200515
Engine, cooling system and fuel system
5.2 Draining and replenishing the engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2 . . . . . 200515
5.3 Draining, filling and bleeding the cooling system. . . . . . . . . . . . . . . . . . . . 5-3 . . . . . 200515
Steering gear and brake system
5.4 Draining and filling, RAS-EC steering circuit . . . . . . . . . . . . . . . . . . . . . . . 5-5 . . . . . 200515
5.5 Bleeding the RAS-EC steering circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7 . . . . . 200515
Drive and chassis
5.6 Draining and filling, differential . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8 . . . . . 200515
5.7 Draining and filling, wheel hub. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9 . . . . . 200515
5.8 Draining and filling, gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10 . . . . 200515
6. CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 . . . . . 200515
6.1 Cleaning the battery terminals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1 . . . . . 200515
6.2 Cleaning the exterior of radiator and air cooler . . . . . . . . . . . . . . . . . . . . . 6-2 . . . . . 200515
6.3 Cleaning the vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-4 . . . . . 200515
6.4 Cleaning gearbox vent(s) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 . . . . . 200515
6.5 Cleaning rear axle vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6 . . . . . 200515
7. LUBRICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-1 . . . . . 200515
7.1 Lubricating according to Y-service lubrication schedule . . . . . . . . . . . . . . 7-1 . . . . . 200515
7.2 Lubricate according to X-service lubrication schedule. . . . . . . . . . . . . . . . 7-3 . . . . . 200515
Page Date
https://www.truck-manuals.net/