2 AGZ 025D through 190D OMM 1087
Table of Contents
Introduction........................................3
Operating/Standby Limits............................ 9
Pressure Drop Curves........................9
MicroTech III Controller .............13
Controller Section Table of Contents ........ 13
Security...................................................... 20
Unit Functions ..................................20
Definitions ................................................. 20
Unit Enable................................................ 21
Unit Mode Selection.................................. 22
Unit States ................................................. 22
Power Up Start Delay................................ 23
Ice Mode Start Delay................................. 23
Unit Status ................................................. 23
Evaporator Pump Control.......................... 24
LWT Target................................................ 25
Unit Capacity Control................................ 26
Unit Capacity Overrides ............................ 27
Circuit Functions .............................29
Definitions ................................................. 29
Circuit Control Logic ................................ 29
Pumpdown Procedure................................ 31
Low Ambient Starts................................... 31
Circuit Status ............................................. 31
Compressor Control................................... 31
Condenser Fan Control.............................. 32
EXV Control.............................................. 34
Liquid Line Solenoid Valve....................... 35
Hot Gas Bypass Solenoid Valve ................ 35
Capacity Overrides – Limits of Operation. 35
Alarms...............................................35
Unit Fault Alarms ...................................... 35
Unit Problem Alarms................................. 37
Unit Warning Alarms .................................38
Circuit Fault Alarms...................................38
Circuit Events.............................................40
Circuit Warning Alarms .............................41
Events ............................................... 41
Unit Events ................................................42
Circuit Events.............................................42
Clearing Alarms .........................................43
Using the Controller ....................... 44
Navigating..................................................45
Menus.........................................................47
Optional Low Ambient Fan VFD .. 60
VFD Interface (HMI).................................61
Recommended Periodic Inspection............65
Optional BAS Interface .................. 65
Startup.............................................. 66
Operation ......................................... 68
Unit Maintenance............................ 72
Planned Maintenance Schedule .................73
Service .............................................. 74
R-410A.......................................................74
Refrigerant Charging .................................75
Liquid Line Solenoid Valve .......................77
Evaporator..................................................77
AGZ-D Troubleshooting Chart...... 78
Warranty Statement ....................... 80
Cover picture: AGZ 190D, 190 nominal tons capacity.
Our facilit
is ISO Certified
©2010 McQuay International. Illustrations and data cover the McQuay International product at the time of publication and we reserve the right
to make changes in design and construction at anytime without notice. ™® The following are trademarks or registered trademarks of their
respective companies: BACnet from ASHRAE;
LONMARK, LonTalk, LONWORKS, and the LONMARK logo are managed, granted and used by
L
ONMARK International under a license granted by Echelon Corporation; Compliant Scroll from Copeland Corporation; ElectroFin from AST
ElectroFin Inc.; Modbus from Schneider Electric; FanTrol, MicroTech III, Open Choices from McQuay International. *Unit Controllers are
L
ONMARK certified with an optional LONWORKS communication module.
To Next Page
Loading...
