IM 1287-6 • REBEL APPLIED ROOFTOP 2 www.DaikinApplied.com
Table of Contents
Introduction..................................3
Nameplate Information ........................3
Hazardous Information Messages ...............3
R-32 Information (R-32 Units Only)...............4
Unit Labels .................................4
Refrigeration Piping...........................9
Condenser and Compressor Piping .............12
VFD Inverter Box............................17
Controlled Component Locations ...............20
Control Panel ..............................21
Installation..................................25
Receiving Inspection .........................25
Unit Clearances.............................25
Compliance Statements ......................25
Ventilation Clearance ........................28
Roof Curb Assembly and Installation ............29
Full Condenser Floor Sealing for Electrical
Penetrations ...............................32
Post and Rail Mounting .......................34
Lifting Guidance ............................34
Transit and Temporary Storage ................36
Shipping Splits .............................37
Unit Piping.................................43
Damper Assemblies .........................51
HEPA Holding Frame, Filter, and Prelter Installation 54
Installing Ductwork ..........................58
Installing Duct Pressure Taps ..................58
Indoor Air Quality (IAQ) Installations .............59
Fan Block-o Plates .........................61
Top Discharge ..............................62
Side Discharge .............................62
Installing Building Static Pressure Sensor Taps ....63
Unit Wiring .................................64
Field Power Wiring ..........................64
Field Control Wiring..........................66
Field Output Signals .........................66
Unit Operation...............................68
Preparing Unit for Operation ...................68
MicroTech® Remote User Interface .............85
R-32 Guidelines (R-32 Units Only) ..............87
Unit Maintenance ............................97
Servicing Control Panel Components ............97
Example Wiring Diagram .....................98
Planned Maintenance .......................112
Daikin Applied Electric Heater Modules .........113
Electric Heater Step Controller ................116
Step Controller Troubleshooting ...............118
Daikin Applied Tubular Gas Heater Series .......123
Sequences of Operation .....................128
Refrigeration Only Controls (ROC) .............130
Maxitrol EXA Star Controller ..................155
Maxitrol EXA Star Valve Over-Traveled State
Calibration ................................157
Furnace Wiring Diagrams ....................160
Rooftop Equipment Warranty Registration Form . 172
In-Warranty Return Material Procedure .........172
©2024 Daikin Applied, Minneapolis, MN. All rights reserved throughout the world.This document contains the most current product information as
of this printing. Daikin Applied Americas Inc. has the right to change the information, design, and construction of the product represented within the
document without prior notice. For the most up-to-date product information, please go to www.DaikinApplied.com.
™® Rebel Applied, MicroTech, and Daikin Applied are trademarks or registered trademarks of Daikin Applied Americas Inc. The following are
trademarks or registered trademarks of their respective companies: BACnet from American Society of Heating, Refrigerating and Air-Conditioning
Engineers, Inc.; Echelon, LonWorks, LonMark, and LonTalk from Echelon Corporation; Modbus from Schneider Electric; and Windows from
Microsoft Corporation, Intertek from Intertek Group PLC.
To Next Page
Loading...
