Daikin Rebel DPS Series - I. INITIAL CHECK; II. FAN DATA; III. START-UP COMPRESSOR OPERATION

 136 

Rebel Equipment Warranty Registration Form (continued)
13F-4157 (06/17) 2
Select Yes or No. If not applicable to the type of unit, select N/A.
I. INITIAL CHECK
A. Is any shipping damage visible? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
B. Has the discharge static pressure reference been properly located in the building? . . . . . . . . . . . . . Yes No N/A
C. Do fans turn freely? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
D. Electrical service corresponds to unit nameplate? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
D1. Voltage at Terminal Block | Disconnect 1–2 __________ V 2–3 __________ V 1–3 __________ V
E. Unit phased correctly? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
F. Is the main disconnect adequately fused and are fuses installed? . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
G. Are crankcase heaters operating, and have they been operating 24 hours prior to start-up? . . . . . . . . Yes No N/A
H. Are all electrical power connections tight? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
I. Is the condensate drain trapped? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
II. FAN DATA
A. Check rotation of supply fan? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . Yes No N/A
B. Voltage at supply fan motor: . . . . . . . . . . . . . . . . . . . . . . . . 1–2 __________ V 2–3 __________ V 1–3 __________ V
C. Supply fan motor amp draw per phase: . . . . . . . . . . . . . . . . . . 1–2 __________ A 2–3 __________ A 1–3 __________ A
D. What is the supply fan rpm? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
E. Record supply static pressure at unit in inches of H
2
0: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
F. Record return static pressure at unit (with outside air dampers closed) in inches of H
2
0: . . . . . . . . . . . . . . . . . __________
III. START-UP COMPRESSOR OPERATION
A. Do compressors have holding charge? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
B. Are compressor shipping brackets removed? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
C. Are compressors rotating in the right direction? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
D. Do condenser fans rotate in the right direction? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Yes No N/A
E. Ambient temperature (°F): . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . __________
F. Compressor amperage:
Compressor #1: . . . . . . . . . . . . . . . . . . . . . . . . . Phase 1___________ Phase 2___________ Phase 3___________
Compressor #3: . . . . . . . . . . . . . . . . . . . . . . . . . Phase 1___________ Phase 2___________ Phase 3___________