DIEBOLD NIXDORF RM4V - 5.3.10 Note Jam in Loopback Transport of Chest Transport; Figure 5-3 RM4 V Middle Platten of Chest Horizontal Transport - Removing Notes from Trans- Port Area

66 pages

Save Page as PDF

To Next Page

To Previous Page

Troubleshooting

5.3.10

5.3.10 Note jam in loopback transport of chest transport

1. Open the middle platten of the chest transport (see Section4.1.9).

Figure5-3: RM4V middle platten of chest horizontal transport

- removing notes from transport area

2. Remove notes from loopback transport (1) of

the chest horizontal transport. Loopback

transport should only be opened to a maxi-

mum 30° angle

3. Close the middle platten of the chest transport (see Section4.1.9).

01750308109 A

Main Page

Table of Contents4
Introduction7
Terminology7
Symbols Used in this Manual7
Basic Information7
Theory of Operation8
Safety9
Section-Specific Warning Notes9
RM4 Safety Precautions10
Description11
Overall View11
Figure 3-1 RM4V-Overview11
Head Unit12
Lower Unit13
Figure 3-2 RM4V Safe Module-Front View13
Figure 3-3 RM4V Safe Module- Transport Pivoted14
Cassettes15
RM4V Standard Cassette15
Figure 3-4 RM4V-Standard Cassette Closed15
Figure 3-5 RM4V-Standard Cassette Opened16
RM4V All in Cassette17
Figure 3-6 RM4V-All in Cassette Closed17
Figure 3-7 RM4V-All in Cassette Opened18
Figure 3-8 RM4V-All in Cassette Bottom Closed19
Figure 3-9 RM4V-All in Cassette Bottom Opened20
Operation21
Basic Operation21
Pulling out / Pushing in the IO Device21
Pulling out / Pushing in the Coin Tray23
Opening/Closing the Upper Transport Unit24
Opening/Closing the Bottom of the Upper Transport Unit25
Opening/Closing the Middle Transport Unit26
Opening/Closing the Lower Transport Unit27
Emptying the Head Compartment28
Opening/Closing the Chest Horizontal Transport30
Figure 4-1 RM4V-Opening Safe Transport30
Figure 4-2 RM4V-Closing the Safe Transport30
Opening/Closing Loopback Transport of Chest Transport31
Figure 4-3 RM4V Loopback Transport of Chest Horizontal Transport - Opening31
Figure 4-4 RM4V Loopback Transport of Chest Horizontal Transport - Closing31
4.1.10 Removing/Inserting Recycling Cassette32
Figure 4-5 RM4V Recycling Cassette - Removing32
Figure 4-6 RM4V - Inserting Recycling Cassette RM4V32
4.1.11 Removing/Inserting All in Cassette33
Figure 4-7 RM4V - Removing All in Cassette33
Figure 4-8 RM4V - Inserting All in Cassette33
Preparing Banknotes34
RM4V Recycling Cassette40
Opening/Closing the Recycling Cassette40
Figure 4-9 RM4V-Recycle Cassette Opening40
Figure 4-10 RM4V Recycling Cassette _Closing Cover40
Inserting/Removing Notes41
Figure 4-11 RM4V - Closing Recycling Cassette41
Figure 4-12 RM4V Recycling Cassette_Moving Contact Pressure41
Figure 4-13 RM4V Recycling Cassette Taking out Notes42
Figure 4-14 RM4V Recycling Cassette_Filling in Notes42
RM4V All in Cassette43
Opening/Closing the All in Cassette43
Figure 4-15 RM4V-Opening All in Cassette43
Figure 4-16 RM4V-Closing the All in Cassette43
Figure 4-17 Ain_Cassette - Locking Cover44
Opening/Closing Bottom Compartment45
Figure 4-18: RM4V-Opening All in Cassette Back Cover45
Figure 4-19 Closing Back Cover All in Cassette45
Inserting/Removing Notes46
Figure 4-20 RM4V Ain_Cassette - Moving Contact Pressure46
Figure 4-21 RM4V Ain_Cassette - Taking out Notes46
Figure 4-22 RM4V Ain_Cassette - Putting in Money47
Cassette Rail Settings for Currencies48
Troubleshooting50
Prerequisite Information50
Recycling Cassette Currency Standards50
Figure 5-1 RM4V-Unacceptable Media51
Note Jam Troubleshooting52
Notes on Operating the Head Unit52
Pulling out / Pushing in the IO Device53
Banknote Jam in the Input/Output Tray55
Note Jam on the Bottom of the Upper Transport Module59
Note Jam in Middle Transport Module60
Note Jam in Lower Transport Module61
Note Jam in Safe Distribution Transport62
Figure 5-2 RM4V-Checking the Safe Transport62
5.3.10 Note Jam in Loopback Transport of Chest Transport63
Figure 5-3 RM4V Middle Platten of Chest Horizontal Transport - Removing Notes from Trans- Port Area63
5.3.11 Note Jam in Cassette Transport64
Figure 5-4 RM4V Cassette Transport - Checking64
5.3.12 Note Jam in Recycling Cassette65
Figure 5-5 RM4V Recycling Cassette - Checking Notes65
5.3.13 Note Jam in All in Cassette66
Figure 5-6 RM4V-Checking All in Cassette66

DIEBOLD NIXDORF RM4V - 5.3.10 Note Jam in Loopback Transport of Chest Transport; Figure 5-3 RM4 V Middle Platten of Chest Horizontal Transport - Removing Notes from Trans- Port Area

Table of Contents