Ezgo 2001 - Page 18

To Next Page

To Previous Page

SAFETY INFORMATION

Page xvi

Owner’s Manual and Service Guide

Read all of manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notes, Cautions and Warnings

Notes:

Main Page

Safety2
Service Guide3
Notes4
- Table of Contents5
- General Operation7
Safety Information7
Preventive Maintenance16
Before Initial Use19
- Fig. 1 Initial Service Chart19
- Preparation of Seats for Service19
- Charger Installation19
  - Fig. 2 Charger Installation20
  - Fig. 3 Charger Receptacle20
Serial Number Plate Location20
- Fig. 4 Serial Number Plate Location20
Controls and Indicators20
- Key/Light Switch20
  - Fig. 5 Key/Light Switch21
- Accelerator Pedal21
  - Fig. 6 Accelerator and Brake Controls21
- Service Brake Pedal21
- Parking Brake21
- Direction Selector21
- Fig. 7 Direction Selector21
- Horn22
- State of Charge Meter22
- Run - Tow/Maintenance Switch (on PDS Vehicles Only)22
- Fig. 9 Run-Tow/Maintenance Switch22
- Controller Diagnostics (PDS Vehicles Only)23
Before Entering Vehicle23
Operating the Vehicle23
- Additional Warnings and Cautions (Applicable to PDS Vehicles)24
Starting Vehicle on a Hill24
- General24
- PDS Vehicle24
- Non PDS Vehicle (with Hand Operated Park Brake)24
- Non PDS Vehicle (with Foot Operated Park Brake)24
- Anti-Stall Feature (PDS Vehicle)25
Coasting25
- Vehicle with PDS25
- Vehicle Without PDS25
Servicing the Electric Vehicle25
Direction Selector Adjustment26
- Fig. 10 Direction Selector Adjustment26
Towing26
Lifting the Vehicle26
- Fig. 11 Lifting the Vehicle27
Routine Maintenance27
- Fig. 12 Lubrication Points27
Rear Axle27
- Checking the Lubricant Level27
  - Fig. 13 Add, Check and Drain Rear Axle Lubricant28
Pds Model Vehicles28
Tires28
- Tire Repair29
- Wheel Installation29
- Fig. 14 Wheel Installation29
Brakes28
- Daily Brake Test28
Light Bulb Replacement29
Care and Cleaning of the Vehicle30
Vehicle Care Products30
Top and Windshield30
Fig. 16 Torque Specifications31
Trailering31
Hardware31
- Fig. 15 Bolt Grades31
Torque Specifications31
Periodic Service Schedule32
- Fig. 17 Periodic Service Schedule32
Batteries and Charging34
- Safety34
Battery34
Battery Maintenance34
- At each Charging Cycle34
- Monthly35
- Electrolyte Level and Water35
  - Fig. 18 Correct Electrolyte Level35
  - Fig. 19 Water Purity Table35
- Cleaning Batteries35
  - Fig. 20 Automatic Watering Gun36
- Prolonged Storage36
  - Fig. 21 Preparing Acid Neutralizing Solution36
  - Fig. 22 Freezing Point of Electrolyte37
- Battery Installation37
  - Fig. 23 Battery Connections37
- Battery Charging37
- AC Voltage38
Troubleshooting38
- Hydrometer38
- Using a Hydrometer39
  - Fig. 25 Hydrometer Temperature Correction39
Battery Charger Maintenance39
- Fig. 26 Cleaning Auxiliary Contact in Charger Plug39
General Specifications41
- Shuttle 4 Electric Powered Personnel / Cargo Carrier42
- Shuttle 6 Electric Powered Personnel / Carrier43
- TE5 Electric Powered 5 Passenger Golf Car44
- TE5 PDS Electric Powered 5 Passenger Golf Car45

Ezgo 2001 - Page 18

Table of Contents

Related product manuals