Firebird Condensing Boiler
6
28
COMMISSIONING
NOTES
E. Check that both room thermostats and boiler
aquastats are calling for heat.
DO NOT START BURNER UNLESS ALL
CLEANOUTS ARE SECURED IN PLACE
F. Reconnect electrical supply and the boiler
should start after the oil heater has reached
temperature. If the burner lock-out activates,this
suggests air in the pump.Wait a minute or so and
try again. If lock-out occurs again, air must be
bled from the pump pressure gauge connection
point once more.
G. View the burner flame through the sight glass - it
should be bright cream/yellow without any sign
of smoke. Use a smoke gun to check that the
burner is burning clean.
H. Run the boiler for about fifteen minutes then
take a CO
2
reading and adjust as necessary.
4. EXTENDED SHUTDOWN
• Turn safety switch on the boiler to the off
position.
• Shut off the fuel supply valve.
Warning: RISK OF FREEZING
If the heating system is shutdown during cold
weather it is possible the boiler could freeze.
To prevent freezing:
• Leave the boiler running to maintain a minimum
heat in the building.
• Drain the heating system and domestic water
system down to remove danger of freezing.
HANDING OVER
A thorough check of the system should be made,
then the homeowner should receive a clear and
concise demonstration of the boiler operation and
any system controls.
This manual, the burner manufacturer manual and
any other instructions should be handed over to the
user, the guarantee card should be completed and
posted, and the user advised about the importance
of annual servicing.
COMMISSIONING RECORD
Should be completed and a copy
kept in the technical file.
SERVICE PERSON
Name:
Company:
Phone:
Address:
Town:
State:
Zip:
To Next Page
Loading...
Need help?
General