Ford 3930 - Page 3

126 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

FORD

Operator's Manual

Tractors

3230,3430,3930,4630,and5030

'

42323051

FOR

CJ

l\EW

HOLLAl\D

I Reprinted I

Table of Contents

Quick Search1
Printing2
Table of Contents5
About this Manual6
Introduction7
Rops9
Safety Decals10
- The Tractor12
- Servicing the Tractor12
Safety Precautions12
- Operating the Tractor13
- Driving the Tractor13
- Operating the P.T.O.14
- Roll over Protective Structure14
- Diesel Fuel14
- Pre-Delivery Inspection15
Pre-Delivery Inspection17
Universal Symbols18
Controls, Instruments and Operation19
Controls, Instruments and Operation20
Operator's Seat20
- Seat Belt and Rops21
- Instrument Panel21
- Proofmeter21
- Engine Coolant Temperature Gauge22
- Engine Oil Pressure Warning Light22
- Instrument Console22
- Hand Throttle22
- Starting the Tractor23
- Key-Start Switch23
- Dual Power Switch23
- Engine Stop Control23
- Coolant Immersion Heater24
- Starting in Cold Weather24
- Starting the Tractor with Jump Leads25
- Parking Brake25
- Stopping the Engine25
- Differential Lock26
- Foot Controls26
- Foot Throttle26
- Footbrakes26
- Transmission and Dual Power27
- Clutch27
- 8 X 2 Constant Mesh Transmission27
- Dual Power Transmission28
Four Wheel Drive29
- Break-In Procedure30
- Attaching P.T.O. Driven Equipment31
- Slow Moving Vehicle Emblem31
Power Take-Off31
- Operating Independent P.T.O.32
- Belt Pulley33
- To Operate the Belt Pulley34
Three-Point Linkage34
- Lift Rods35
- Top Link35
- Telescopic Stabilizers36
- Linkage Categories36
- Hydraulic Lift Rocker36
- External Check Chains37
- Flexible Link Ends38
Hydraulic System38
- Upper Link Draft Control Operation39
- Position Control Operation40
- Operating Remote Cylinders with the A.S.C. Valve41
- Draft Control Operation with Position Control41
Remote Control Valves42
- Standard Remote Control Valves43
- Deluxe Remote Control Valves45
- Operating Double-Active Cylinders47
- Operating Single-Acting Cylinders47
- Operating Continuous Flow Hydraulic Equipment47
- Attaching and Detaching Trailed Equipment48
- Bleeding Remote Cylinders48
- Swinging Drawbar48
- Front Wheel Track Adjustment50
- Safety Chain50
Track Adjustment51
- Rear Wheel Track Adjustment55
- Power Adjusted Rear Wheels56
- Power Adjust Procedure58
- Changing Track Width Range58
Tractor Weighting60
- Cast Iron Weights61
- Weighting Limitations61
- Liquid Ballast62
Tire Inflation64
Lubrication and Maintenance65
Lubrication and Maintenance Chart66
- Access Panels68
- Hood Side Panel68
- Radiator Cowling and Grille68
- Radiator Grille68
- Engine Coolant Recovery System69
- Engine Oil Level69
- Radiator and Oil Cooler70
- Power Steering70
- Pre-Cleaner70
- Oil Bath Air Cleaner70
- Servicing the Dry Air Cleaner71
- Dry Air Cleaner71
- Fuel Filter/Sediment Separator73
- Clutch Pedal Free Play Adjustment73
- Tires73
- Front and Rear Wheel Nuts73
- Rear Axle Oil Level74
- Belt Pulley Oil Level74
- Front Axle Differential Oil Level74
- Front Axle Hub Oil Levels75
- Grease Fittings and Pivots75
- Engine Oil and Filter77
- Transmission Oil Level78
- Footbrake Adjustment79
- Hydraulic Oil Filter79
- Handbrake Adjustment80
- ROPS Bolts81
- Fan Belt81
- Front Wheel Bearings83
- Starter Motor Pinion83
- Valve Tappet Clearance84
- Bleeding the Fuel System86
- Rear Axle Oil87
- Transmission Oil87
- Front Axle89
- Front Axle Hub Oil89
- Belt Pulley Oil90
- Power Steering Oil and Filter90
- Coolant Inhibitor/Filtration System91
- Tractor with Coolant Filter92
- External Headlights94
- Headlight Bulb Replacement94
- Engine Coolant94
General Maintenance94
- Grille-Mounted Headlights95
- Rocker Switch Bulb Replacement96
- Battery96
- Fuses96
- Alternator97
- Preparing the Tractor for Use after Storage98
- Tractor Storage98
- Engine Idle Speed98
- Specifications99
- General Dimensions100
- Lubricants108
- Front Tire Pressures and Permissible Loads109
- Rear Tire Pressures and Permissible Loads113
- Road Speeds113
- Road Speed Decal120
- Reduction Gear Set120
Index121

Related product manuals

Preview: Ford 9N

Preview: Ford 2000

Preview: Ford 8N-8NAN

Preview: Ford 601 series

Ford 601 series

Preview: Ford fordson dexta

Ford fordson dexta

Ford 5000 super major

Ford fordson power major

Ford fordson major diesel