EasyManua.ls Logo

Gardner Denver GDD60F - User Manual

Gardner Denver GDD60F
15 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Cod. 710.0138.72.00 Rev.10 – 02.2022 © Copyright 2022 Gardner Denver - All rights reserved 1 - 10
DIRECT EXPANSION COMPRESSED AIR DRYERS
Operators Manual
GDD4F
GDD7F
GDD9F
GDD12F
GDD18F
GDD24F
GDD30F
GDD37F
GDD43F
GDD50F
GDD60F
GDD80F
GDD100F
GDD130F
GDD160F

Table of Contents

Questions and Answers

  • T
    Trevor PalmerAug 22, 2025
    Why is the pressure in my Gardner Denver GDD60F line low?
    • K
      Keith DiazAug 23, 2025
      Low pressure in your Gardner Denver Dehumidifier line can be caused by several factors. Check for ice formation in the evaporator and inspect/replace the probe if needed. Ensure the compressed air inlet/outlet is connected properly to prevent clogs. Also, check if air flows continuously through the condensate drainage, which may indicate a jammed drainage solenoid valve that needs cleaning or replacement. You may also want to check the condition of any filter.
  • P
    Paul LinNov 6, 2025
    What to do if there is water in my Gardner Denver Dehumidifier?
    • W
      wyattlloydNov 6, 2025
      If you find water in your Gardner Denver Dehumidifier, there could be several reasons. First, ensure there is power in the line; if not, restore it. For GDD130-160F models, check that the phases are connected correctly. Inspect the cabling and the electronic control board, replacing them if problems persist. Also, confirm the dryer is on by pressing the ON/OFF switch for one second and wait two minutes after switching it on, in case it is in stand-by. Other possible causes include improperly connected compressed air inlet/outlet, flow rate/temperature of entering air exceeding nominal values, high ambient temperature, a dirty condenser (clean it), a malfunctioning condensate drain (clean the filter mesh or check/replace the no loss condensate drain), or an improperly positioned/faulty temp...

Summary

SYMBOLS AND LABELS USED IN THE MANUAL AND ON THE DRYER

WARRANTY

1. GENERAL INFORMATION

1.1 FUNCTIONAL DESCRIPTION

Explains how Gardner Denver refrigerated air dryers remove moisture from compressed air and their operating principles.

1.2 USE OF THE MACHINE IN SAFE CONDITIONS

Details safety precautions and compliance with European safety directives for dryer installation, use, and maintenance.

2. INSTALLATION

2.1 ACCEPTANCE AND HANDLING

Instructions for inspecting the unit upon receipt and proper handling procedures to prevent damage.

2.2 STORAGE AND INSTALLATION LOCATION

Guidance on storing the dryer when not in use and selecting an appropriate installation site with environmental considerations.

2.3 UNPACKING

Steps for safely unpacking the dryer, including handling packaging materials and accessories.

3. START UP

3.1 CONTROL PANEL

Overview of the electronic control system, its keys, and digital display for dryer operation and settings.

3.2 BEFORE START UP

Pre-start checks and recommendations to ensure correct operation and performance during initial use.

3.3 START UP

Procedure for starting the dryer after initial installation or prolonged inactivity, including sequence and delays.

DISPLAY VISUALIZATION AND SIGNALLING LEDS

3.1.1 KEYS FUNCTION

Detailed explanation of the functions for each key on the dryer's control panel (ON/OFF, TEST, SET, DOWN, UP).

3.1.2 CONDENSATE DISCHARGE PARAMETERS PROGRAMMING

3.1.3 DISPLAY INDICATIONS

Description of error messages and codes displayed by the controller, their causes, outputs, and recommended actions.

3.1.4 REMOTE SIGNALING ALARM

4. MAINTENANCE, TROUBLESHOOTING AND DECOMMISSIONING

4.1 MAINTENANCE

Scheduled maintenance tasks and intervals (weekly, monthly, yearly) to ensure optimal dryer performance and longevity.

4.2 TROUBLESHOOTING

Guidance on identifying and resolving common operational issues and understanding normal operating behaviors.

TROUBLESHOOTING DISPLAY INDICATIONS AND CAUSES

4.3 DECOMMISSIONING

Gardner Denver GDD60F Specifications

General IconGeneral
BrandGardner Denver
ModelGDD60F
CategoryDehumidifier
LanguageEnglish

Related product manuals