GAS GAS ENDURO 4T EC 2014 User Manual (English)

Questions and Answers:

S
Stephanie EvansAug 5, 2025
What to do if my GAS GAS ENDURO 4T EC 2014 Motorcycle engine does not start?
- L
  Lucas RoyAug 5, 2025
  If your GAS GAS Motorcycle engine won't start, several factors could be at play. If the motorcycle has been inactive for a long time, unload the old fuel from the tank and refill with new fuel. If the spark plug is dirty or wet, clean or dry it, replacing it if necessary. If the engine is flooded, close the fuel tap, remove the spark plug, put a gear and push the bike several feet with the throttle fully open to empty the pre-compression pan. Then, mount the spark plug and attempt to start the bike. Repeat if necessary, cleaning the spark plug if it gets wet again.
A
Andrew SmithAug 12, 2025
Why does my GAS GAS ENDURO 4T EC 2014 engine start but then stops?
- D
  Daniel MyersAug 12, 2025
  If your GAS GAS Motorcycle engine starts and then stops, it could be due to an incorrect air supply or a lack of fuel. Try closing the starter, cleaning the fuel tank air vent, and adjusting the air cleaner duct to correct the air supply. Also, ensure that the fuel tank is full.
A
adavisAug 20, 2025
What to do if my GAS GAS Motorcycle engine overheats?
- R
  Richard HardinAug 20, 2025
  If your GAS GAS Motorcycle engine is overheating, it might be due to insufficient coolant or a dirty radiator. First, fill up the coolant and check the refrigeration system for watertightness. If that doesn't solve the problem, inspect the radiator; clean the radiator fins or replace the radiator if it's partially restricted.
S
swatkinsAug 28, 2025
What to do if the electric starter motor does not crank on my GAS GAS ENDURO 4T EC 2014?
- M
  Mary PowellAug 28, 2025
  If the electric starter motor on your GAS GAS Motorcycle isn't cranking, the issue might stem from a blown starter relay fuse or a discharged battery. Begin by removing the seat and inspecting the starter relay fuse. Also, while the seat is removed, check the battery voltage.

GAS GAS ENDURO 4T EC 2014 Specifications

General

Year	2014
Manufacturer	GAS GAS
Model	ENDURO 4T EC
Category	Motorcycle
Displacement	449.3 cc
Compression Ratio	12.5:1
Fuel System	Electronic Fuel Injection
Starter	Electric
Rear Suspension	Monoshock
Seat Height	940 mm
Engine Type	Single cylinder, 4-stroke
Engine	4-stroke, single cylinder
Ignition	Electronic
Transmission	6 speed
Front Suspension	USD fork
Front Brake	Single disc
Rear Brake	Disc
Bore x Stroke	95.0 x 63.4 mm

Summary

GENERAL INFORMATION

Introduction

Welcome message and overview of the GAS GAS EC/XC 2014 models.

Legal Notices

Manufacturer's right to modify specifications without prior notice.

Notices and Warnings

Important safety notices regarding dangers and warnings.

Preliminary Warnings

Essential safety advice on helmet use, modifications, and riding conditions.

CONTROLS AND COMPONENTS LOCATION

EC 4T Component Identification

Identifies components on the EC 4T 250/300/450cc model.

XC 4T Component Identification

Identifies components on the XC 4T 250/300/450cc model.

EC 4T Controls Overview

Details controls located on the handlebars for EC 4T models.

IDENTIFICATION AND SPECIFICATIONS

Vehicle Identification Plate

Location and details of the manufacturer's identification plate.

Steering Lock Operation

Instructions for locking the motorcycle's steering column.

Technical Specifications

Detailed technical data for EC250F, EC300F, and EC450F models.

ELECTRICAL AND TORQUE DATA

Electrical Diagram

Wiring diagram and component identification for the electrical system.

Torque Values

Recommended torque specifications for various motorcycle components.

MULTIFUNCTION GAUGE

Gauge Overview and Setup

Introduction to the gauge, its buttons, and initial setup.

Setting Adjustments

Procedures for setting clock, maintenance reminders, and units.

Screen Modes and Measurement

Explanation of display screens and wheel circumference measurement.

Homologation Requirements

Details on EU type-approval components for road use.

OPERATING INSTRUCTIONS

Starting Procedure

Step-by-step guide for starting the motorcycle.

Break-in Procedure

Recommended intervals and methods for breaking in the new motorcycle.

DAILY INSPECTIONS

Pre-Ride Checks (Fluids and Controls)

Essential checks for fuel, oil, coolant, brake fluid, and controls.

Pre-Ride Checks (Brakes, Tires, Chassis)

Checks for brake wear, discs, pads, tires, spokes, and chain.

Pre-Ride Checks (Suspension and General)

Inspection of suspension, spokes, chain, and external elements.

CLEANING AND STORAGE

Motorcycle Cleaning Procedures

Step-by-step guide for washing and cleaning the motorcycle.

Motorcycle Storage Guidelines

Procedures for storing the motorcycle for extended periods.

SERVICE AND MAINTENANCE

Maintenance Table

Table outlining maintenance tasks and their frequencies.

Clutch, Throttle Cable, and Spark Plug Service

Maintenance procedures for clutch, throttle cable, and spark plug.

Air Filter and Carburetor Service

Procedures for air filter cleaning and carburetor idling adjustment.

Engine Oil and Coolant Service

Steps for changing engine oil, filter, and coolant.

Brake System Maintenance

Procedures for brake adjustment, pad replacement, and fluid checks.

Chain and Tire Maintenance

How to check and adjust chain tension and tire pressure.

Battery Service

Instructions for changing or charging the motorcycle battery.

ADJUSTMENTS AND SUSPENSION TUNING

Carburetor Tuning

Adjusting fuel mixture based on throttle, altitude, and temperature.

Suspension Settings

Guide to adjusting front fork and rear shock settings for performance.

Footpegs Height Adjustment

How to adjust the height of the footpegs.

TROUBLESHOOTING

Engine and Transmission Issues

Identifies and provides solutions for engine and transmission problems.

Chassis and Electrical Issues

Identifies and provides solutions for chassis, brake, and electrical issues.

WARRANTY MANUAL

Warranty Terms and Exclusions

Information on warranty terms, coverage, and exclusions.

Related product manuals

GAS GAS Enduro Series

72 pages

GAS GAS Enduro 2T 250 2018

77 pages

GAS GAS EC250-4T 2010