– 32 –
QuickFreeze™ Fan Motor
A 12-VDC motor is mounted in front of the freezer
evaporator cover. The fan motor and fan housing
are replaced as a complete assembly.
When activated (See Control Features), the
QuickFreeze™ fan circulates freezer air directly
onto food placed on the aluminum tray. Food can
be frozen up to 2 times faster, reducing moisture
loss when food is thawed. A constant 13.6 VDC is
provided to the fan from the main control board.
For testing, the motor can be run for short periods
using a 9-volt battery. Observe circuit polarity.
Connect the red wire to the positive (+) battery
terminal and the remaining wire to the negative (-)
battery terminal.
BLACK
BLACK/WHITE
BLUE (RPM)
BLUE/WHITE (MODEL)
RED
WHEN APPLICABLE
WHEN APPLICABLE
J3-1J2-8J2-7J2-6J2-5J2-4J2-3J2-2J2-1J3-3
RED
RED
FF FAN
CC FAN
TAN
BLACK/WHITE
YELLOW
QUICK FREEZE
FAN
FZ COMPARTMENT
EVAP. FAN
COND. FAN
YELLOW
RED
WHITE
RED
YELLOW
BLUE
WHITE
YELLOW
YELLOW/BLACK
WHITE/SILVER (COMM)
+12V RED
RED/YELLOW
BC
FAN
MAIN CONTROL BOARD
Condenser Fan
The fan is mounted in the machine compartment
with the no-clean condenser. The fan and fan
shroud are mounted on one end of the condenser,
and the other end of the condenser is blocked.
When the fan is operating, air is pulled from the
center of the condenser, drawing air in through the
coils. The air is then exhausted over the compressor
and out the right side of the refrigerator.
Inlet air is available through the left front and left
rear of the machine compartment. A rubber divider
strip underneath the refrigerator divides the inlet
and outlet sides of the machine compartment.
Rear
Front
Divider Strip
Housing
Fan
Motor
0.375"
1/2"
Air Flow
0.50" ± 0.05"
Bracket
The rear access cover must be tightly fi tted to
prevent air from being exhausted directly out of the
rear of the machine compartment, bypassing the
compressor.
To Next Page
Loading...
