Generac Portable Products 5500XL Generator
BEFORE STARTING THE
ENGINE
Add Oil
_ ARNING! Any attempt to crank or start the
engine before it has been properly filledwith the
recommended oil mayresult in an enginefailure.
To fill your engine with oil:
• Place generator on a level surface.
• Clean area around oil fill and remove oil fill cap.
• Select the oil's viscosity grade and fill engine with oil
following the instructions given in the engine owner's
manual. Do Not overfil!!
• Install oil fill cap.
NOTE: The generator's revolving field rides on a pre-
lubricated and sealed ball bearing that requires no
additional lubrication for the life of the bearing.
Add Gasoline
_ ANGER! Explosion Hazard! Never fill fuel tank
indoors.Never fillfuel tank when engine is running
or hot Do Not light a cigarette or smoke when
filling the fuel tank.
_ WARNING! Do Not overfill the fuel tank.
Always allow room for fuel expansion.
• Use regular UNLEADED gasoline with the Generator
engine. Do Not use premium gasoline. Do Not mix oil
with gasoline.
• Clean area around fuel fill cap, remove cap.
• Add unleaded regular gasoline, slowly to fuel tank. Be
careful not to overfill. Allow about I/2" of tank space for
fuel expansion (Figure 3).
1/2" Air Space Tank
• Install fuel cap and wipe up any spilled gasoline.
IMPORTANT: It is important to prevent gum deposits
from forming in essential fuel system parts such as the
carburetor, fuel filter, fuel hose or tank during storage.
Also, experience indicates that alcohol-blended fuels (called
gasohol, ethanol or methanol) can attract moisture which
leads to separation and formation of acids during storage.
Acidic gas can damage the fuel system of an engine while in
storage.
To avoid engine problems, the fuel system should be
emptied before storage of 30 days or longer. See "Storage"
on page 12. Never use engine or carburetor cleaner
products in the fuel tank or permanent damage may occur.
/
6
To Next Page
Loading...
Need help?
General
