8.- TROUBLESHOOTING
INCIDENT LIKELY CAUSE SOLUTION
Starter does not turn.
Defective battery. Replace the battery.
Battery isolator open. Close battery isolator.
Defective starting system. Contact technical services.
Starter functioning properly.
Faulty voltage detector on control
module.
Contact technical services.
Lacking fuel. Refill the fuel tank.
Stops with cause. Emergency has occurred. Take appropriate measures.
Stops for no apparent reason.
Emergency not indicated due to faulty
LED indicator.
Contact technical services.
Does not stop when emergency
occurs.
Defective shutdown system.
Press emergency stop button.
Contact technical services.
Generator does not stop when in
stop position.
Faulty control unit. Press emergency stop button.
Defective shutdown system. Contact technical services.
High voltage at no load.
Excessive speed.
Contact technical services.
Alternator failure.
Low voltage at no load.
Reduced speed.
Contact technical services.
Alternator failure.
Correct voltage but low when
on load.
High load. Adjust the unit’s loads.
Underspeed on load.
Contact technical services.
Alternator failure.
Voltage unstable.
Voltage meter damaged.
Contact technical services.
Engine unsteady.
Strange noise inside the unit. Various causes.
Make sure nothing is preventing the unit
from functioning properly
.
Contact technical services.
High alternator temperature.
Ventilation openings obstructed.
Remove obstructions from internal and
external ventilation openings.
Possible overload. Check loads.
IN THE ELECTRICAL PANEL
Engine does not start
Engine starts
ORIGINATING IN ENGINE’S INTERIOR
Unit in operation
9.- PROTECTION FROM THE ENVIRONMENT
Once the electrical generator has been installed, it is necessary to clean the packaging, accessories, electrical
tools, etc., that were used during the installation process.
When it is time to dispose of the batteries, in keeping with environmental regulations it is advisable to take them to
an authorized recycling center.
For a cleaner environment, recycle all possible items and be sure to not throw electrical components in with the
regular garbage so as to comply with European Directive 2002/96/EC. These items should be stored separately until
being taken for ecological recycling.
To Next Page
Loading...