Title: SPEC, ZX TRANSMITTER FAMILY Sheet 5 of 7 Rev: B Dwg: 817-2350-085
ZX Transmitters Specifications – HD models
GENERAL
FM power output range:
1
ZX2500: 625 W – 2750 W
ZX3750: 950 W – 4125 W
ZX5000: 1250 W – 5500 W
ZX7.5: 1900 W – 8250 W
ZX10: 2500 W – 11000 W
FM+HD power output range:
2
(HD signal injection ratio -20
dB)
ZX2500: 500 W – 2050 W
ZX3750: 750 W – 3100 W
ZX5000: 1000 W – 4125 W
ZX7.5: 1500 – 6200 W
ZX10: 2000 W – 8250 W
HD power output range:
3
ZX2500: 250 W – 950 W
ZX3750: 375 W – 1450 W
ZX5000: 500 W – 1925 W
ZX7.5: 750 W – 2900 W
ZX10: 1000 W – 3850 W
RF output connector:
4
ZX2500: EIA 1-5/8” flangeless, 50 ohms
ZX3750: EIA 1-5/8” flangeless, 50 ohms
ZX5000: EIA 1-5/8” flangeless, 50 ohms
ZX7.5: EIA 1-5/8” flanged, 50 ohms
ZX10: EIA 1-5/8” flanged, 50 ohms
Excitation: Flexstar HDX Exciter.
RF amplifers: MOSFET, broadband (no-tune), hot plug
modular, universal (same type all tx models), 4.5 kg.
Power supplies: Switchmode, auto-ranging, hot plug modular,
universal, 2.5 kg.
Frequency range: 87.5 - 108.0 MHz, programmable in 10 kHz
steps.
Frequency stability: +/- 150 Hz, 0° to 50°C using high
accuracy internal (59.535 MHz) TCXO. 10 MHz input for
synchronization to external (GPS) reference. Automatic
switching to internal oscillator if external reference fails.
Power stability: +/- 0.25 dB.
Reverse power: Protected against open or short circuit, all
phase angles. Capable of operation into infinite VSWR
with user-adjustable foldback threshold. Threshold set to
2.5% of FM nameplate power level at factory.
Harmonic / spurious suppression: Internal harmonic filter
meets or exceeds all FCC, IC, CE, Chinese requirements.
Meets or exceeds standard NRSC-5A emission limits in all
modes.
1
VSWR 1.2:1 or less. De-rate to nameplate rating for VSWR
up to 1.5:1.
2
VSWR 1.2:1 or less. De-rate to 70% of nameplate rating for
VSWR up to 1.5:1.
3
VSWR 1.2:1 or less. De-rate to 35% of nameplate rating for
VSWR up to 1.5:1.
4
EIA 3-1/8” flanged available as option, ZX7.5 and ZX10.
Modulation types: FM digitally synthesized direct to channel,
HD digital direct to channel, FM+HD digital direct to
channel.
Operating modes: “On-the-Fly” switching between FM only,
HD only, FM+HD modes.
FM modulation capability: Greater than +/- 300 kHz.
Asynchronous AM S/N ratio: 50 dB minimum below
equivalent 100% amplitude modulation by 400 Hz using 75
ȝs de-emphasis (no FM modulation present).
Synchronous AM S/N ratio: 50 dB minimum below equivalent
100% amplitude modulation with 75 ȝs de-emphasis and
400 Hz high-pass filter (FM deviation +/-75 kHz by a 1 kHz
sine wave). Measured at wideband input.
AC mains requirement: 90 - 264 V
5
, 47 - 63 Hz, IEC C14
inlet for exciter and following connections to power
amplifier:
ZX2500/3750: 190 - 264 V
6
, 47 - 63 Hz, triple IEC
C20 inlets. Configurable on-site for single or three-
phase connection: 190 - 264 V single phase, 190-
264 V delta, 190 - 264 V wye, or 330 - 450 V wye.
ZX5000: Same as 3750 W model except triple
PowerCon NAC3MPA inlets.
ZX7.5 and ZX10:
Screw terminal connections.
Option: 190 - 264 V, 47 - 63 Hz, delta
Option: 330 - 450 V, 47 - 63 Hz, wye
Option: 190 - 264 V, 47 - 63 Hz, dual single-phase
(top and bottom amplifiers)
Power consumption: (FM mode at nameplate power level)
ZX2500: 4700 W max; 4300 W typical
ZX3750: 7000 W max; 6350 W typical
ZX5000: 9300 W max; 8500 W typical
ZX7.5: 14000 W max; 12700 W typical
ZX10: 18600 W max; 17000 W typical
Power Factor (displacement): 0.98 typical.
Phase rotation/balance: all AC inputs independent.
Observation of correct phase rotation and balance not
required.
Mains restart: > 80% output power in less than 5 seconds after
AC mains failure.
Altitude: 3000 m elevation above mean sea level.
Ambient temperature range: 0 - 50
o
C at sea level, upper limit
de-rated 2
o
Centigrade per 300 m elevation AMSL.
Humidity: 95%, non-condensing.
Dimensions: Standard 19” (48.3 cm) EIA rack; 1RU = 4.45 cm
(1.75”)
ZX2500: 16 RU amp + 1 RU exciter, 62 cm (25”) depth
ZX3750: 16 RU amp + 1 RU exciter, 62 cm (25”) depth
ZX5000: 16 RU amp + 1 RU exciter, 62 cm (25”) depth
ZX7.5: 44 RU rack, 96 cm (38”) depth
ZX10: 44 RU rack, 96 cm (38”) depth
Weight, less exciter (all modules installed):
ZX2500: 67 kg (148 lbs) approx.
ZX3750: 81 kg (179 lbs) approx.
ZX5000: 95 kg (210 lbs) approx.
ZX7.5: 225 kg (500 lbs) approx.
5
Certified to 100-240 V nominal range +/- 10% testing margin.
6
Certified to 208-240 V nominal range +/- 10% testing margin.
To Next Page
Loading...