Hatco TOAST-QWIK TQ-400 Series User Manual

Form No. TQ2M-1219
13
English
OPERATION
Control Panel – TQ-400, -800, -1200, and -1800 Series, Single-Sided Toaster
Power I/O
(on/off) Switch
Color Control
Top Heat
Control
Warning
Light
Power Save
Button
Bottom Heat
Control
Control Panel – TQ-400, -800, -1200, and -1800 Series, Two-Sided Toaster
Power I/O
(on/off) Switch
Color Control
Top Heat
Control
Warning
Light
Power Save
Button
Bottom Heat
Control
Operating TQ-400, -800, -1200, and -1800
Series
1. Plug the unit into a properly grounded electrical receptacle
of the correct voltage, size, and plug configuration. See the
SPECIFICATIONS section for details.
2. Move the Power I/O (on/off) switch in the I (on) position.
3. Adjust the Top Heat ( ) and/or Bottom Heat ( ) controls.
• For two-sided toasting, turn the control and control
clockwise to the highest setting.
• For one-sided toasting, turn the control clockwise
to the highest setting and turn the control counter-
clockwise to the lowest setting.
NOTE: TQ-400BA, -800BA, -800HBA, -1800BA, and -1800HBA
toasters are designed specifically for toasting one side
of a bread product, such as a bun or bagel. These
models toast with the cut side facing up.
NOTE: When toasting a single-sided product such as a bun
or bagel, place the product with the cut side facing up.
Adjust the Bottom Heat control to a light setting, toast
two slices of bread product and adjust the Top Heat
and/or Bottom Heat controls as needed.
4. Turn the Color Control to the lowest position ( ) while the
toaster heats up.
NOTE: Allow approximately 15 to 20 minutes for a warm-up
period.
5. After warm-up period, toast two slices of bread product.
Adjust the Color Control if needed.
NOTE: If toasted bread product is too dark with the Color
Control set on the lightest setting, adjust the Top Heat
and/or Bottom Heat controls as needed. (Allow 15 to
20 minutes for toaster to re-adjust to new setting before
resuming operation.)
NOTE: To toast moist products such as English Muffins, rye
bread or whole wheat, slow the conveyor by turning the
Color Control knob to a darker setting (clockwise).
IMPORTANT NOTE
If the Warning light comes on, the unit may be overheating.
Turn off and unplug the unit. Refer to the “Daily Cleaning”
procedure to clean the cooling fan vents. If the unit does
not function properly after cleaning the cooling fan vents,
contact an Authorized Service Agent or Hatco for assistance.

Hatco TOAST-QWIK TQ-400 Series Specifications

General

Brand	Hatco
Model	TOAST-QWIK TQ-400 Series
Category	Toaster
Language	English