48
No. Designation Technical data Application
P/N of manufacturer
Sap
1. Universal charger and discharger
type UL 10
Or other suitable commercial units
Refer to the UL 10 datasheet Charge and discharge of airborne batteries 552 0200 000
2. Voltmeter 0-40 V accuracy 1.0 Voltage test Commercial unit
3. Digital voltmeter 0-40 V accuracy 1.0 Voltage test Commercial unit
4. Digital multimeter 0-40 V accuracy 1.0 Voltage, current, resistance test Commercial unit
5. Insulation tester Insulation test Commercial unit
6. Temperature measuring unit
0-100°С tolerance ±1%
Temperature test of the temperature sensor Commercial unit
7. Digital thermometer
50…+150°С
Temperature test Commercial unit
8. Tool box with special HAWKER
®
tools Size No: 42
Complete:
aerometer, thermometer, protective gloves, brush,
funnel, spec. wrench, valve spanner, spare parts
(5 vents, 5 pole nuts, 5 limiting caps, 5 sealing
rings, 5 spring washers).
For batteries 44/40/38/27 (Ah) Battery maintenance 929 1480 770
9. Tool box with special HAWKER
®
tools Size No: 43
Complete is analogous to Size No: 42.
For batteries 25/22 A·h Battery maintenance 929 1480 780
10. Tool box with special HAWKER
®
tools Size No: 44
Complete is analogous to Size No: 42.
For batteries 17/15/7/4 (Ah) Battery maintenance 929 1480 790
11. Insulated torque wrench 0.5-20.0 Nm (5-200 kpcm) Tightening cell pole nuts Commercial unit
12. Cell puller For all battery types Pulling cells off, undoing and tightening
pole nuts
929 1380 459
13.
Plastic valve spanner М14
For batteries
45/40/38/27/25/22 Ah
Undoing and tightening vents 929 1380 4800
14.
Plastic valve spanner М10
For batteries
17/15/7/4 Ah
Undoing and tightening vents 929 1380 4810
15. Protective gloves Commercial
16. Protective glasses Commercial
17. Syringe hydrometer with aerometer Topping cells up
Density measurement
Adjusting the electrolyte level, testing the
electrolyte density
929 2014 054
18. Electronic density meter Commercial
19. Thermometer (fracture-proof)
0-80°С
Measuring battery temperature Commercial unit
20. Vessel for filling up with distilled water 1 liter Adjusting the electrolyte level 928 7611 030
21. Plastic brush Cleaning the battery Commercial unit
22. Resistor for discharging single cells 1 ohm / 2 watt Overhaul 4611908
23. Fixture for heating thermostats in switch
assemblies
Heating thermostats Commercial unit
24. Device for testing pressure on vents Testing response pressures Commercial unit
APPENDIX 5:
RECOMMENDED TOOLS AND CONSUMABLES FOR BATTERY MAINTENANCE
The document reference is online, please check the correspondence between the online documentation and the printed version.
To Next Page
Loading...
Need help?
General
