Heat-N-Glo 6000 DVTFL User Manual

WARNING
IF THE INFORMATION IN
THESE INSTRUCTIONS IS
NOT FOLLOWED EXACTLY, A
FIRE OR EXPLOSION MAY
RESULT CAUSING PROPERTY
DAMAGE, PERSONAL INJURY,
OR LOSS OF LIFE.
- Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
- What to do if you smell gas
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
Heat-N-Glo Fireplace
Models:
8000 DVTFL
6000 DVTFL
6000 XLT
6000 ARCH
SL-42 DVT
U.S. Patents 4,793,322; 4,875,464; 5,000,162 and Patents Pending
Canadian Patent 1,297,746
Installers Guide
WARNING: IMPROPER
INSTALLATION, ADJUSTMENT,
ALTERATION, SERVICE OR
MAINTENANCE CAN CAUSE
INJURY OR PROPERTY DAMAGE.
REFER TO THIS MANUAL. FOR
ASSISTANCE OR ADDITIONAL
INFORMATION CONSULT A
QUALIFIED INSTALLER, SERVICE
AGENGY, OR THE GAS SUPPLIER.
Underwriters Laboratories Listed
484-980-B 7/97
READ THIS MANUAL BEFORE INSTALLING
OR OPERATING THIS APPLIANCE. THIS
INSTALLERS GUIDE MUST BE LEFT WITH
APPLIANCE FOR FUTURE REFERENCE.
1.This appliance may be installed in an
aftermarket, permanently located,
manufactured (mobile) home, where
not prohibited by local codes.
2. This appliance is only for use with the
type of gas indicated on the rating
plate. This appliance is not convertible
for use with other gases, unless a
certified kit is used.
Please contact your Heat-N-Glo Fireplace
dealer for any questions or concerns. For the
number of your nearest Heat-N-Glo dealer,
please call 612-890-8367.
Printed in U.S.A.
Copyright 1997,
Heat-N-Glo Fireplace Products, Inc.
6665 West Highway 13, Savage, MN 55378

Heat-N-Glo 6000 DVTFL Specifications

General

Type	Direct Vent Gas Fireplace
Glass Type	Ceramic Glass
Firebox Material	Steel
Fuel Type	Natural Gas or Propane
Efficiency	Up to 70%
Log Set Material	Ceramic Fiber

Summary

Safety and Warning Information

General Safety Precautions

Essential safety warnings and prohibitions for appliance use and maintenance.

Approvals and Codes

Approval Listings and Codes

Details certification standards and listing laboratories for fireplace models.

Installation Codes and Compliance

Outlines requirements for conforming to local and national installation codes.

High Altitude Installation Guidelines

Provides instructions for adjusting input rating based on elevation.

Getting Started

Introduction to Heat-N-Glo Gas Fireplaces

Overview of direct vent gas fireplace design and operation.

Pre-installation Preparation and Warnings

Essential steps and warnings before starting the installation process.

Installing the Fireplace

Fireplace Location and Clearances

Guidance on selecting a location and required clearances for the fireplace.

Framing the Fireplace Structure

Instructions and dimensions for framing the fireplace opening.

Vent System Installation

Procedures for installing direct vent components and terminations.

Positioning, Leveling, and Securing

Steps for properly placing, leveling, and securing the fireplace unit.

Gas Control Systems Overview

Explains the two types of gas control systems: Standing Pilot and DSI.

Gas Supply Line Installation

Instructions for connecting the gas supply line to the fireplace.

Gas Pressure Requirements

Specifies minimum and maximum gas pressure requirements for operation.

Fireplace Wiring and Electrical Connections

Guidance on electrical wiring for Standing Pilot and DSI systems.

Finishing and Surround Installation

Procedures for finishing the fireplace surround with non-combustible materials.

Installing Trim, Logs, and Ember Material

Instructions for placing logs and ember material and installing trim.

Pre-Lighting Checks

Final checks for gas leaks, obstructions, and faulty components before lighting.

Lighting the Fireplace

Instructions on how to safely light the fireplace.

After Installation: Manual Retention

Directive to leave the installation manual with the appliance for future reference.

Fireplace Maintenance

Fireplace Maintenance Schedule

Table outlining recommended maintenance tasks and frequencies.

Checking Flame Patterns

Visual inspection of flame patterns for steady, non-lifting flames.

Checking Vent System

Inspecting the external vent cap for obstructions.

Cleaning Glass Door

Instructions for cleaning the glass door without damage.

Replacement Parts and Accessories

Standing Pilot Ignition Parts

Lists parts for standing pilot ignition systems with part numbers.

DSI Ignition System Parts

Lists parts for Direct Spark Ignition (DSI) systems with part numbers.

Common Parts for Both Systems

Lists parts common to both ignition systems, including glass specifications.

Optional Accessories

Lists optional accessories like fan kits, remote controls, and trim kits.