Why do all actuators have no power on my Hitachi Excavators?
S
Samantha WarrenSep 1, 2025
If all actuators on your Hitachi Excavators have no power, it could be due to a malfunction from a worn hydraulic pump, requiring replacement. The main relief valve set pressure in the control valve might be decreased, needing adjustment. A lack of hydraulic oil requires refilling. Also, the suction strainer in the hydraulic oil tank might be clogged, so clean it. Finally, air absorption from the oil suction side requires retightening.
J
James MurrayAug 31, 2025
What causes Hitachi ZAXIS 30U-5N engine to run irregularly?
A
Alexandria GayAug 31, 2025
If your Hitachi Excavators engine runs irregularly, it could be due to a faulty fuel system or engine control system, both requiring repair and adjustment. Another possibility is water or air in the fuel system, which needs to be drained or bled.
M
Mrs. Lisa MillerAug 30, 2025
Why Hitachi ZAXIS 30U-5N Excavators batteries discharge quickly after being charged?
D
Dennis HoldenAug 30, 2025
If the batteries in your Hitachi Excavators discharge quickly after being charged, the cause might be a shorted cable or battery separator, both needing repair or replacement. Another possibility is increased sediment in the battery, in which case you should replace the battery.
S
Stacy DavisAug 28, 2025
Why hydraulic oil temperature increases in Hitachi ZAXIS 30U-5N?
J
Jim SinghAug 29, 2025
If the hydraulic oil temperature in your Hitachi Excavators is increasing, it might be due to a stained oil cooler, which needs cleaning. Also, check the engine fan belt tension and adjust if it is insufficient.
W
wanda25Aug 27, 2025
Why does my Hitachi ZAXIS 30U-5N engine stall soon after starting?
K
kim73Aug 27, 2025
If your Hitachi Excavators engine stalls soon after starting, the issue could be due to several factors. The idle speed might be too low, requiring repair and adjustment. A clogged fuel filter or pre-fuel filter (for ZX50U-5N, ZX60USB-5N models) could also be the cause; replace the fuel filter element after draining any water, or clean/replace the pre-fuel filter element. Additionally, a clogged air cleaner can lead to stalling, so clean or replace the element. The engine control system or injection pump might also be faulty, requiring repair and adjustment.
M
Mary RoyAug 27, 2025
What to do if starter rotates on Hitachi Excavators but it won't start?
P
Patricia LindseyAug 27, 2025
If the starter rotates but your Hitachi Excavators won't start, consider these possibilities: the machine might be out of fuel, so check for leaks and refill. There could be air in the fuel system, requiring you to bleed it. A clogged fuel filter is another potential cause; drain any water and replace the element. If the fuel is frozen, warm the fuel pump with hot water or wait for warmer temperatures. Alternatively, the injection pump or preheat system might be faulty, requiring repair and adjustment.
P
Pam BookerAug 25, 2025
What to do if coolant temperature is too high in Hitachi ZAXIS 30U-5N Excavators?
A
Angela PhamAug 26, 2025
If the coolant temperature in your Hitachi Excavators is too high, it could be due to several reasons. First, check if the coolant level is low and refill if necessary. Another possible cause is insufficient fan belt tension, which requires adjustment. Inspect the rubber hoses for damage and replace them if needed. A faulty thermostat or coolant temperature gauge can also cause this issue, and both would need replacement.
M
Michael JohnsonAug 25, 2025
How to fix Hitachi ZAXIS 30U-5N Excavators batteries that will not be charged?
P
Peter WatersAug 25, 2025
If the batteries of your Hitachi Excavators are not charging, the issue might stem from a broken battery separator, requiring a replacement. Alternatively, there could be a faulty regulator, which needs adjustment or replacement. A faulty ground line requires repair, or the alternator itself might be faulty, which means it needs to be repaired or replaced.
To Next Page
General
