5
LP-543 Rev. 12.15.15
AREAS LIKELY TO HAVE CONTAMINANTS
Spray cans containing fluorocarbons
Dry cleaning/laundry areas and establishments
Chlorinated waxes/cleaners
Chlorine-based swimming pool chemicals
Calcium chloride used for thawing
Refrigeration repair shops
Sodium chloride used for water softening
Paint or varnish removers
Plastic manufacturing plants
Hydrochloric or Muriatic acid
Furniture refinishing areas and establishments
New building construction
Antistatic fabric softeners used in clothes dryers
Chlorine-type bleaches, laundry detergents, and cleaning solvents
Adhesives used to fasten building products
Table 1
B. DURING OPERATION
1. Check for Gas Leaks
Frequently check the gas pipe and connections for leaks with a soapy solution. If air bubbles appear during the test, gas is
leaking. Close the gas supply valve and call your gas supplier for inspection.
After any repair of the gas pipeline or replacement of the gas regulator, call a qualified service technician to observe the installation and
replacement before restoring power to the boiler. Failure to do so could result in a fire or explosion, substantial property damage,
severe personal injury, or death.
2. Check Exhaust Vent and Intake Pipe for Proper Ventilation
Ensure there is sufficient ventilation while operating the boiler.
Improper ventilation could result in premature boiler failure. Such
failures ARE NOT covered by boiler warranty.
Exhaust gas entering the living space can cause carbon monoxide
poisoning. If exhaust gas should leak into the living space:
Shut down the boiler.
Close the gas valve.
Open windows for ventilation.
Ensure that the CO detectors are operating properly.
Immediately call a qualified service technician to inspect the boiler and
exhaust vent pipe. Any damages to the exhaust vent pipe should be
repaired immediately. Failure to do so could result in substantial property
damage, severe personal injury, or death.
3. Burn Warning
Take caution when inspecting the boiler and its internal
components, exhaust vent, and/or water pipes. These components can get extremely hot during boiler operation.
4. Combustibles and Flammable Material Warning
Do not store combustibles or flammable materials in the vicinity of this boiler. Do not hang anything from the exhaust pipe.
Storing flammable or combustible materials near this boiler could result in a fire or explosion, substantial property damage, severe
personal injury, or death.
5. Check for Water Leaks
Do not attempt to clean the heating system. Call a qualified service technician for service.
If you notice any leaks, immediately call a qualified service technician. Leaks in boiler or piping must be repaired at once.
C. TROUBLESHOOTING AND GENERAL CAUTIONARY STATEMENTS
DO NOT use this boiler for any purposes other than those specifically described by HTP, Inc (to provide central heating and domestic
hot water). Using this boiler for unapproved purposes WILL VOID the warranty, and could result in property damage, serious personal
injury, or death.
To Next Page
Loading...
Need help?
General
