IPC 1404 E - Page 56

ENGLISH
17
MAINTENANCE SCHEDULE
A: On receipt
B: Twice a week
C: Each week
D: Every 20 hours
E: Every 50 hours
F: Every 100 hours
G: Every 150 hours
H: Every 300 hours
I: Every 400 hours
I: Every 400 hours
CHECK A B C D E F G H I
Centre brush
: check for nylon
cord or rope wrapped around
the brush and remove if
necessary
Centre brush
: check the state
of wear of the brush
Side brushes
: check the state
of wear of the brushes
Flaps/bin gasket
: check the
state of wear of flaps and
gaskets
Dust filter
: check that the filter
is clean and undamaged
Tyres
: check that the tyres are
in good condition and the sides
are free from cuts
Steering
: grease the steering
chain
Battery
: check the acid level
Hydraulic circuit
: check oil
level
Hydraulic circuit
: check pipes
and hoses for damage
Internal combustion engine
:
change engine oil
Internal combustion engine
:
change filter oil
Internal combustion engine
:
change air filter
Internal combustion engine
:
clean air filter
Internal combustion engine
:
check engine oil level
General control
: check the
tightness of nuts and screws
See engine instructions
See engine instructions
See engine instructions
See engine instructions
See engine instructions