IPC CT15 - Technical Information; Danger Zones and Hazards; Safety Information; Safety Regulations and Compliance

GB
TECHNICAL INFORMATION
General description
This machine is a scrubber drier for sweeping, washing and drying at, horizontal, smooth or moderately rough,
even and obstacle free oors in civil and industrial premises. It is available in both battery and cable versions to
meet all running time and weight requirements.
The scrubber drier spreads a solution of water and detergent in the correct concentration on the oor and then
scrubs it to remove the dirt. By carefully choosing the detergent and brushes (or abrasive disks) from the wide ran-
ge of accessories available, the machine can be adapted to a wide range of combinations of types of oor and dirt.
A suction system incorporated in the machine dries the oor after washing by means of the low pressure gene-
rated in the dirty water tank by the suction motor. The squeegee connected to the tank collects the dirty water.
Legend
The main parts of the machine are as follows (g. A):
► the detergent tank (g. A, ref. 1): contains and transports the mixture of clean water and detergent;
► the dirty water tank (g. A, ref. 2): collects the dirty water picked up from the oor after washing;
► control panel (g. A, ref. 3);
► head assembly (g. A, ref. 4): the main element is the brush which distributes the detergent solution on
the oor and remove the dirt;
► squeegee assembly (g. A, ref. 5): wipes and dries the oor by collecting the water.
Danger zones
► Tank assembly: when using certain detergents, danger of irritation for eyes, skin, mucous membranes
and respiratory tract and of asphyxia. Danger represented by the dirt collected from the environment
(germs and chemical substances). Danger of crushing between the two tanks when the dirty water tank
is replaced on top of the detergent tank.
► Control panel: danger of short circuit.
► Bottom of washing head: danger due to brush rotation.
► Rear wheels: danger of crushing between the wheel and chassis.
► Battery compartment (in the detergent tank): danger of short circuit between the battery poles and
presence of hydrogen during charging.
Accessories
► Bristle brushes: for washing delicate oors and polishing;
► Polypropylene brushes: for normal oor washing;
► Tynex brushes: for removing accumulated stubborn dirt on resistant oors;
► Drive disks: enable the following disks to be used:
► Yellow disks: for washing and polishing marble and similar surfaces;
► Green disks: for washing resistant oors;
► Black disks: for thorough washing of resistant oors with stubborn dirt.
► S.P.E. battery charger CBHD1
SAFETY INFORMATION
Safety regulations
INFORMATION
Read the “User Manual” carefully before start-up and use or before performing maintenance or any other
work on the machine.
IMPORTANT
Rigorously respect all instructions in the Manual (in particular those relating to danger and important
information) and on the safety plates tted to the machine.
The Manufacturer declines all liability for damage to people or things resulting from failure to observe
the instructions.
25