- 57 -
Frequency of check
1. Clean fuel tank.
2. Change transmission oil and filter
cartridge.
3. Apply grease to clutch release hub.
4. Check that bearing, cylinder head
and pump connections are tight.
5. Apply grease to the front wheel hubs
(right and left sides, two points each)
6. Front axle case.
Change fuel filter.
1. Clean engine cooling system
2. Change break oil
Recharge Battery if necessary.
Change scale inhibitor and coolant.
Change air cleaner element
Change anti-freeze and coolant
1. Change battery, if necessary.
2. Change radiator hose and hose
clamps.
3. Change fuel pipe and hose clamps.
4. Change hydraulic hoses and hose
clamps.
5. Change fuel pipe, water pipe and
connecter of oil pressure pipe.
Check
100
( 26.3 u.s.gal.)
58
(15.25 u.s.gal.)
Apply a small amount of
bearing grease
45g (1.6 oz.) of bearing
grease.
4.8
(1.25 u.s.gal.)
3.5
( 0.93 u.s.gal.)
1. Tighten cock of fuel filter
and then replace filter.
2. Dampen gasket with fuel
and hand tighten.
3. Make sure all air is bled
from fuel line after
installation of new filter.
0.47
( 0.12 u.s.gal.)
Notes Remarks
Every 300 hours
Every 400 hours
Every 500 hours
Every one to two
months
Every 3 months
Every year or
every 6 times of
cleaning
Every year
Every 2 years
To Next Page
Loading...
