KLIPPO LAWNMASTER - Trouble Shooting (Continued); Engine and Vibration Issues

43
TROUBLE SHOOTING
Troubleshooting schedule
Problem Possible Cause Action
Engine does not start, runs erratically or
experiencing power loss.
Throttle not in choke / start position. Move throttle to choke / start position.
Fuel tank empty or fuel shut off valve
closed.
Fill tank with recommended fuel grade
and open fuel shut-off valve.
Air cleaner element is dirty. Service or replace air cleaner.
Spark plug loose. Tighten spark plug.
Spark plug cable disconnected. Refi t cable to spark plug.
Defective spark plug. Replace the spark plug.
Spark plug gap incorrect. Adjust the gap or replace the spark
plug.
Carburettor is fl ooded with fuel. Move throttle to ‘stop’ position, pull the
starter cord 5 - 6 times, move throttle
to ‘run’ and start engine.
Dirt, water or stale fuel in the tank. Drain and clean fuel tank. Refi ll with
clean fresh fuel before starting.
Vent hole in the fi ller cap is blocked. Clean or replace fi ller cap.
Engine skips at high speed. Blocked engine cooling fi ns and air
passages.
Clean thoroughly around engine.
Engine idles poorly. Blocked engine cooling fi ns and air
passages.
Clean thoroughly around engine.
Engine overheats. Faulty spark plug. Replace the spark plug.
Too low oil level. Check oil level and top up if necessary.
Excessive vibration and / or noise. Worn or damaged bearings. Remove and inspect suspect bearings,
replace if necessary.
Worn or damaged drive chains and / or
sprockets.
Remove and inspect suspect chains
and sprockets, replace if necessary.
Worn or damaged cutting reel or bot-
tom blade.
Inspect cutting reel and bottom blade
for excessive wear or damage. The
knifes will require regrinding or replace-
ment by your authorised Klippo Agent
Oil leaks from muffl er or air cleaner. Engine oil sump over fi lled. Check oil level and drain excessive oil.
Mower tipped or handled incorrectly. Check oil level, air cleaner and spark
plug and correct as necessary.